Gas Recirculation Valve (egr Valve) problems of the 2006 Chevrolet Malibu

Three problems related to gas recirculation valve (egr valve) have been reported for the 2006 Chevrolet Malibu. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2006 Chevrolet Malibu based on all problems reported for the 2006 Malibu.

car   Gas Recirculation Valve (egr Valve) problem 1
Failure Date: 07/21/2014

After four (4) minutes of driving car at 6:30am in the morning, temperature was 58 degree on 7/21/2014, the engine shut off. All powered functions associated w/vehicle did not work. All idiot lights flashed on. The message in display was "engine disabled. " car was pulled over and shut off. After 4-5 minutes of rest, the car was re-started and driven back home about another two (2) miles.

car   Gas Recirculation Valve (egr Valve) problem 2
Failure Date: 06/30/2010

My 2006 Malibu maxx has 73000 miles on it. While driving, the air conditioning stopped blowing cool air. The outside temp was 95 degrees and my daughter and I both have asthma. Took the car to the dealer today and will cost $1100 to repair and replace the a/c compressor! a car this young should not have this problem. My daughter and I were both using inhalers by the time we arrived back home!.

car   Gas Recirculation Valve (egr Valve) problem 3
Failure Date: 08/25/2008

Vehicle stalls intermittently when stopped and idling. This occurs when backing up and also when idling. It seems to occur more so when the air temperature outside is very hot. Usually when it is around 85 - 90 degrees outside. Vehicle usually restarts ok. Only one instance when engine was turned off twice while idling, it would not restart until engine cooled down. Then was able to start engine. Mechanics have not been able to detect problem even when vehicle was scanned for codes. Have taken it to different automotive service shops including dealerships and no one can find the problem because they state it is intermittent. Air temperature outside of vehicle seems to be a key factor with car stalling when temperature very hot. The car has never overheated when this occurs.




Switch Make:
Switch Model:
Safety Ratings of Malibu Cars
Fuel Economy of Malibu Vehicles
Malibu Service Bulletins
Malibu Safety Recalls
Malibu Defect Investigations