Diesel Engine problems of the 2006 Ford F-350
Seven problems related to diesel engine have been reported for the 2006 Ford F-350.
Diesel Engine problem #1
The car is a 2006 Ford F-350 sd. Was driving on a heavy traffic highway, in the middle lane, and truck just quit running. This is unjustifiable!! over $5000. 00 in repairs to get to get this truck to run! why hasn't Ford issued a recall on this notorious problem on these diesel engines?! I will continue to pursue a class act lawsuit over this, I do believe there are enough Ford owners very unhappy regarding these continuing issues. This diesel engine issue occurred Friday, August 17, 2012.
Diesel Engine problem #2
The car involved is a 2006 Ford F-350 sd. Vehicle identification number (VIN): 1FDWF37P26_. 2006 Ford f350 super duty. Attorney writes on behalf of client in regards to reimbursement for repairs the consumer noticed smoke billowing out of the exhaust. Shortly thereafter, a warning light appeared on the dashboard and the vehicle lost power. The consumer took the vehicle to the dealer, where they replaced the turbo under warranty. Two months later, the problem occurred again. The vehicle was promptly taken back to the dealer, where the turbo was replaced again. Three months later the turbo was replaced for a third time. On April 20, 2012 the consumer experienced the failure again. He noticed smoke and the vibration was getting progressively worse each time the turbo failed. When he went back to the dealer, he was informed it would cost $212. 00. On April 23, 2012 the truck began billowing a thick cloud of smoke upon being started. The next day, the vehicle continued to stall as the consumer attempted to make his way to the dealer. Upon his arrival at the dealer, the vehicle finally stalled for good and would not re-start. The total cost for the repairs were $ 5,715. 41. This diesel engine issue occurred 08/10/2011.
Diesel Engine problem #3
The car involved is a 2006 Ford F-350 sd. The VIN of this vehicle was 1FTWW31P96_. I had a 05 Ford super duty 6. 0 liter diesel that had 3 new turbo's put on due to skoring. Ford replaced all 3. When turbo's go out you loose power. I have a 06 super duty that has 26828 miles. The warranty just went out 6/16/11. Ford had to put on another turbo because it was skored. Ford did pay $750 and I had to pay $1142. I was going down highway and lost power and had to limp home pulling a 5th wheel camper. I have read where Ford has had a lot of problems with the 6. 0 liter diesel engine. I am upset that Ford that Ford did not cover this problem fully because of all problems they have had with the engine. The property damage below was just to the turbo itself. I am wondering if you as an agency have had other complaints like this and to see if their are any recalls or are going to be any recalls on this problem. The engine only had 26828 miles on it and I do not drive it every day because I have a department vehicle. To drive to work because I am on call 24/7. I voiced my concern to Ford and now I am voicing my concern to this agency,. This issue happened on Friday, July 29, 2011.
Diesel Engine problem #4
The car involved was a 2006 Ford F-350 sd. VIN of the vehicle was 1FTWW33P96_. Engine hesitation or stall upon acceleration. It was Jan. 1, 2006 when this diesel engine issue occurred.
Diesel Engine problem #5
The vehicle having this issue was a 2006 Ford F-350 sd. The vehicle's vehicle identification number (VIN) is 1FTWW33P26_. Check engine light on several times and unable to identify problem. 10/10/06 egr position error but stated okay at this time. Severe loss of power found 4 injectors replaced 11/27/06. 12/08/06 check engine light on with replacement of egr valve 12/18/06. Turns over without start with puffs of black smoke. Engine got hot. Smoke smelled of antifreeze and lost all power. Replaced 4 injectors, fuel pump, fuel line fitting. 1/12/07 severe loss of power, truck at garage. The failure date was Jan. 12, 2007.
Diesel Engine problem #6
My 2006 Ford F-350 truck keeps stalling while the vehicle is moving and when it shuts off it will not start. I have taken it to the dealership twice in the past month. The first time they could not find the problem and said, "to come pick up the vehicle and that it was running". The 2nd time, I had the truck towed to the same dealership service department. They did the computer check and said, "they could not find anything wrong with it and the technician told my husband that if it happens again to check the fuel switch and reset it. " the truck has done this 5 times since being returned from the dealers which was (April 25, 2007) and each time my husband has to hit the fuel cut off switch. Today is 5/2/07. This problem occurred on 04/03/07.
Diesel Engine problem #7
The reporting person's vehicle is a 2006 Ford F-350 sd diesel. The contact was driving approximately 20 mph when the vehicle became resistant to his attempts to accelerate with the illumination of the egr valve warning light. The dealer refilled the coolant but to no avail. The contact stated he had experienced the failure at least twice. The vehicle was not repaired. The contact stated that he had not operated the vehicle since the failure. The approximate failure and current mileage was 111,000. The failure date was Sun., Sep. 19, 2010.
Other Engine And Engine Cooling related problems of the 2006 Ford F-350:
|Problem Category||Number of Problems|
|Gas Recirculation Valve (egr Valve) problems||8|
|Diesel Engine problems||7|
|Engine And Engine Cooling problems||6|
|Manifold/header/muffler/tail Pipe problems||2|
|Check Engine Light On problems||2|
|Loud Engine Noise problems||1|
|Engine Oil Leaking problems||1|
|Engine Turbo-charger problems||1|
|Engine Head Gasket Failure problems||1|
|Engine Cooling System problems||1|
|Blown Head Gasket problems||1|
|Car Stall problems||1|