Table 1 shows one common engine and engine cooling related problems of the 2021 Audi A6.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems |
Thermostat housing and oil cooler bracket leaking coolant with only 56k miles on the car.
The contact owns a 2021 Audi A6. The contact stated while driving at an undisclosed speed, the vehicle overheated. The engine overheating and the low coolant warning light illuminated. In addition, the engine seized. The vehicle was taken to the dealer where it was diagnosed with a coolant leak and a failed coolant pump vacuum. The contact was informed that the coolant pump vacuum assembly needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the failure was a known failure of the vehicle. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA hotline and report the failure. The failure mileage was approximately 80,000.
Car reported an engine restarter issue (with battery symbol) and recommended to contact the dealer. Car next shut down automatic restart system, and air conditioning stopped working. Within a short period of time (same day), the car listed a red battery symbol and advised to stop the car. After doing so and contacting the Audi roadside, the car was listing a series of issues on multiple symptoms while also saying in the warning message "still okay to drive". These systems included steering, braking, and what seemed to be other sensors the car powers. Finally (and within 5 minutes of the previous message of being okay to drive), the warnings were continuous and started including the transmission. The car stopped accelerating (we were on the expressway) and we thankfully got to the side of the road. This was an enormously dangerous situation as the car became fully disabled and we were subject to limited options of relief from a major traffic area. Within 30 minutes of being disabled, no electrical charge was present in the car, including emergency flashers, making the situation more dangerous as it was nighttime, so we had to abandon the car and walk down the expressway to find a hotel. Could not even put the car in neutral for the tow. Service is initially reporting a failure of the restart generator. This appears to be an alarmingly common issue with Audis.