Tank Assembly problems of the 2002 Buick Rendezvous

The contact owns a 2002 Buick Rendezvous. The contact stated that gasoline fumes were emitted around the vehicle. The vehicle was taken to an independent mechanic. The technician stated that there was a fuel leak and as a result of the failure, the fuel tank needed to be replaced. The vehicle had not been repaired. The contact referenced NHTSA campaign id 07v349000 (fuel system, gasoline). However, the manufacturer indicated that it was never a recall but only a special coverage but the statute of limitations had passed. The approximate failure mileage was 190,000.

I am the owner of a 2002 Rendezvous, my name is, I went an got a oil change a few mos back & found out I had a leak at my fuel fill neck/fuel tank. I did research & found out that from 2002-2007 there was a problem with these parts with my make. There was a special service coverage extended on this. . Read more...

The contact owns a 2002 Buick Rendezvous. The contact stated that the fuel system, air conditioning and the engine failed. The fuel gauge would not indicate when the fuel tank was full or empty. The air conditioning would not blow cool air and the engine was exhibiting an abnormal knocking noise. The vehicle was not taken to the dealer or repaired. The approximate failure mileage was 200 and the current mileage was 1,794.

2002 Buick Rendezvous with leaking gas tank not being covered under recall by gm #06230.

Smelled gas in garage and moved our Buick Rendezvous and found gas on the floor under the gas tank and saw gas dripping from the gas tank. I took the vehicle to my local repair shop. It was determined after inspection the gas tank has fracture and allowed gas leak. The repair shop located the recall from gm. Buick advised the repair shop and myself the tank was not part of the recall and would not be covered by Buick. I had the repair shop replaced the fuel tank at my cost. Failure to make the repair could have cause a fire. Even though the VIN number wasn't part of the recall it should have been covered by Buick because the defect was consistent with the defective fuel tanks of the recall.

Fuel tank leakage from fracture of the fuel tank inlet.

The contact owns a 2002 Buick Rendezvous. The contact stated that the vehicle has been overheating. She also noticed something in her driveway and could smell gasoline fumes intermittently. A local mechanic inspected the vehicle and stated that there may be a recall related to the failures. Through online research, the contact located a TSB relating to the failure; however, the dealer stated that no recalls were available. She then provided the dealer with the information for TSB number 07203a and they acknowledged that there was a service bulletin. The dealer stated that if they could not locate a leak in the fuel tank, they would not make any repairs to the vehicle. The VIN was unknown. The failure and current mileages were 48,500.

Fuel leak at point where fill tube joins gas tank.

The contact owns a 2002 Buick Rendezvous. The contact smelled fuel inside the passenger compartment. He took the vehicle to the dealer and was informed that the inlet check valve was fractured. He attempted to repair the failure, but the entire fuel tank had to be replaced. The manufacturer stated that the VIN was not included in NHTSA campaign id number 07v349000 (fuel system, gasoline:storage), even though the vehicle was experiencing the exact same failure. The failure mileage was 93,000 and current mileage was 103,000. Updated 03-25-08 the consumer stated the manufacturer decided to include in the recall and has disbursed a reimbursement check. Updated 03/25/08.

The contact owns a 2002 Buick Rendezvous. When the vehicle was parked and the windows were rolled up, the contact smelled a strong gasoline odor. The vehicle will be taken to a private mechanic for a diagnosis. The manufacturer stated that the VIN was not included in NHTSA campaign id number 07v349000 (fuel system, gasoline:storage) and they would not be able to assist. The current mileage was 81,000 and failure mileage was 78,000. The fuel tank was cracked. Updated.

I am experiencing a gas leak at the fuel tank inlet filler pipe, just as the NHTSA investigation (ea07006) has described. This is very disturbing as my whole family is transported in this vehicle. It appears the leak is where the icv and fuel tank are joined. This is on my 2002 Buick Rendezvous cxl. I just noticed it today (8/10/2007) when my garage smelled of gasoline. The temperatures in this area have been very hot (100+ degrees) as of late.

Leaking gas tank.

Due to a persistent smell of gasoline in the vehicle and the check engine light coming on, we took the vehicle to our local repair shop. They detected a leak in fuel tank and had to replace the fuel tank. In December, I received a recall notice that described this problem as a manufacturer defect and that I may be eligible for reimbursement of the repairs. I sent the required documentation and have been getting the run around since. I have been told: 1. VIN # not in recall - yes it is. And it has been registered in arizona for 3 years. 2. Repairs not done by a gm certified dealer - nothing in the documentation I was sent stated only repairs done by a dealer certified repair shop would be honored 3. The team is reviewing it, but no one will give me a name or contact number for "the team".

Purchased my used 2002 Rendezvous cx January . 07. After March 07 when filling with gas, tank leaks gas where filler tube and tank meet. Took to dealer, they say, need new tank total repair 968. 15. Called Buick customer service, after 1 week they say, no assistants is available. Case closed. I have a reference number. I did plead to no avail. Ea07-006. Pco.

Gas tank leaking at the rear seam on 2002 Buick Rendezvous. Replace tank NHTSA action number rq06009. Ea07-006. Pco.

On Tuesday Nov. 22, 2006 I noticed a strong smell of gas in my garage where my 2002 Buick Rendezvous was parked. I looked under the vehicle and noticed the gas tank was leaking where the filler pipe meets the tank. I immediately called Buick to see if I could bring the car in and was told yes. I was informed that because the tank is plastic it would have to be replaced at a cost of approximately $1100. Parts and labor. I also asked if this has happened to other Rendezvous and was told yes and was also told this happens to the chevy envoy. I then asked if Buick would pay for the repairs if this is an apparently defective tank and was told that a gm knows about it but has not issued a recall I must absorb the repair cost. I was lucky that my car was parked in doors and I smelled the gas leaking. What happens to the poor soul who parks out doors and does not know his tank is leaking. Does it take fire or death for the people at gm to realize their mistake and fix these tanks before someone is injured or killed. I would like to know how I can get the information as to how many of these tanks were defective and how many were covered by warranty and how many replaced att the owners expense. I had an extended 75,000 mile warranty that just expired last month or I would not have had to endure an $1112. 06 repair bill to ensure my family's safety. Thanking you in advance, a dissatisfied gm customer.

Fuel gauge for 2002 Buick Rendezvous cxl was reading incorrectly. The operator of the vehicle ran out of gas while gauge indicated full tank. Dealership indicated that the vehicle needed a new fuel kit. Dealership (certified Buick dealership) installed new fuel kit. Next day, there was a puddle of fuel on driveway. Vehicle was leaking gasoline from fuel tank. Dealership was notified and able to correct. During same time period, transmission was not properly shifting gears. The vehicle would never shift into overdrive and would sometimes shift abruptly or very hard (jerks). Dealership indicated that the vehicle needed new transmission. Dealer corrected. Several months ago, vehicle turning became increasingly difficult and power steering failed intermittently. Dealership indicated needed an entire new rack and pinion. Dealer corrected. Current defect involves coolant leaking into engine due to a leaking lower intake manifold gasket. Several service bulletins out for same component in this and other gm vehicles. Dealer indicated that this will cause extensive damage to engine if not corrected. Currently scheduled to have vehicle serviced in 2 weeks. Total repairs for 4 year old vehicle are now over $8000. All repairs have been paid by owner and none have been covered by dealership.

Buick Rendezvous 2002 model cx fwd fuel leaking where filler neck attaches to gas tank. Rear spring broken; vehicle not used for towing or heavy loads.

Bought a used 2002 Rendezvous in December of last year. First month of ownership, oil light on. Took to pennzoil. Oil changed. Two weeks later, low oil light on. Took back. Low on oil. Took to garage, says it's leaking from around the trasnsfer case (they think) and can't fix it. Now big problem: traveling to an appointment. Had just filled gas tank about 30 miles before, low fuel light came on. Fuel gauge went to empty. Started surging and idling so fast it could drive itself. Just quit at 60 miles an hour in the middle of the road. Caused a slight fender bender, but no one was hurt. Everyone agreed it was ok not to call the police for a report. (mistake) called onstar. They said something about a relay getting too hot, probably causing part of the problem, but not all of it. Had it checked out by a mechanic friend. Related he had no idea what is causing the problem. Husband took it out a few days later to see if it was acting any better, drove just fine and then did the same thing. Quit in the middle of the road. Will have to take it to the dealership, but have no money. Stretched our budget to buy reliable transportation for our family. Was told Buick was a reliable automobile. Has turned out to be the worst we've ever owned. Also, have had to have the wheel bearings changed twice, and we've only had it since December. Mechanic says it's a chronic problem with Rendezvous. The ones we got to replace the bad ones were even bad. Have no idea where to turn. It is unsafe! I have no way to transport my children without taking our two smaller cars everywhere. I would apppreciate any assistance you could provide. Thanks and have a blessed day!.

Safety hazard: cracked fuel tank leaking gasoline/gasoline vapors on 2002 Buick Rendezvous. The car is driven on city/highway pavement and has not been in any crash or driven on rough or offroad terrain. Note that on Nov. 10, 2003 Buick issued a recall on 2004 Rendezvous for cracked fuel tanks. See NHTSA recall id number 03v454000. We noticed strong gasoline odors in our garage beginning in mid-September. On September 30, we could not start the car and had a Buick dealer tow the car to dealership to identify the reason for the no start and check for gasoline fumes. The dealership identified a bad cell in the car's battery, worn fuel level sensors and a cracked fuel tank. This complaint only deals with the cracked fuel tank unless NHTSA's investigation identifies a link between the others. The vehicle was purchased from don stein Buick in overland park, KS and towed to john bailey Buick in buford, GA. On today, oct 5, 2005, I will be picking up the vehicle following replacement of the gas tank. I have asked the bailey dealership to make the cracked gas tank available for my review and transport. I intend to take pictures of the tank prior to accepting custody of it. The NHTSA hotline representative was unable to determine if NHTSA has any chain of custory procedures for conveying the cracked tank to NHTSA custody. (note: I do not know the exact purchase date but do know the car was purchased in July 2002. I have listed July 15, 2002 as an approx. Date. ).

2002 Buick randezvouz with 20,000 miles. Failure of plastic collar on top of the fuel tank for no aparent reason. Fuel spills out of the tank in considerable quantity to make a the situation a dangerous hazard. For the past two weeks the unit has been at the dealer's shop waiting for the new fuel tank which might have the same design or manufacturing problem.