Headlights problems of the 2005 Chevrolet Aveo

The contact owns a 2005 Chevrolet Aveo. The contact received a recall notice for NHTSA campaign number: 14v261000 (exterior lighting: headlights); however, the part needed for the repair was unavailable. The dealer was uncertain as to when the part would become available. The manufacturer was notified of the issue. The contact experienced a failure with the headlights. The approximate failure mileage was 33,000.

In addtition to the daytime headlights randomly shutting off, the clock in the center of the dashboard will disapear untill I turn on the headlights then it reapears. ~ just before the vehicle stalls just after starting in the morning here in the fla. Sun, all the gauges go up then back down. ~ this 2005 Chevrolet Aveo lt hatchback, is having more and more electrical problems but the dealer, rosner Chevrolet, refuses to fix the problem without a charge, since the vehicle is not a fire hazard or on a recall list. ~ I feel as though gm and the dealer, are hiding serious electrical issues from the buyer either due the cost of repairing the problem or due to some of the manufacturing being done in south korea. Or untill people start dying from these problems. ( or untill we start getting lawyers ).

2005 Aveo lt ~ day or night the safety headlights (headlights / other) will just shut off for no reason after being on for less than an hour. ~ it's not fun driving on I-95 here in east central fla. And all of the sudden your headlights disappear ! ! ! ~ one month after we bought the car (used) from rosner Chevrolet (melbourne, fla. ) the front end suspension started squeaking, ~ and the thermostat housing came apart.

The contact owns a 2005 Chevrolet Aveo. The contact stated that the headlights failed. The contact inspected the vehicle and found that the wiring harness connectors shorted due to overheating, which burned and melted the wires. The dealer advised that NHTSA campaign number: 14v261000 (exterior lighting) would only repair the drl module and it would not replace any additional failure caused by the recall. The contact also stated that the engine valve cover gasket was defective and caused the engine fluid to leak. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 80,000.

Tl-the contact owns a 2005 Chevrolet Aveo. The contact stated while driving, the inside and headlights had suddenly shut off. The failure recurred multiple times. The vehicle was taken to the dealer for a diagnosis and they were unable to locate a problem. The manufacturer had not been notified of the failure. The VIN had not been included NHTSA campaign number:14v261000(exterior lighting). The approximate failure mileage was 22,000. Gb.