Table 1 shows one common steering related problems of the 2022 Chevrolet Bolt Ev.
| Problem Category | Number of Problems |
|---|---|
| Steering problems |
While driving at a low speed (approx. 5–10 mph), the front passenger-side lower ball joint suffered a catastrophic structural shear without warning. This caused the wheel assembly to collapse outward and the cv axle to pull out of the transmission. The failure caused a complete loss of steering control, veering the vehicle into a curb. Physical evidence (outward axle pull and high-side rim scratches) indicates the mechanical failure preceded the impact. This occurred at only 38,155 miles on a 2022 Chevrolet Bolt Ev. Outward dislocation: photos show the cv axle pulled out of the transmission and the wheel leaning out (positive camber). A curb impact would push these components in. This proves the wheel fell away from the car first. Pre-impact grinding: the interior barrel of the rim and the brake dust shield show heavy rotational grinding and metal-on-metal scoring. This confirms the suspension collapsed while the wheel was still spinning at speed, prior to the car coming to a stop. Structural shear: the lower ball joint stud suffered a complete transverse shear. High-resolution photos of the broken stud face show distinct "beach marks" (concentric rings), which are the physical fingerprint of a slow-growing metal fatigue crack rather than a sudden impact fracture. Rim damage profile: deep gouges are located on the flat face of the wheel spokes rather than the outer lip. This confirms the wheel was already at an extreme tilt (collapsed) when it made contact with the curb. Conclusion: the vehicle was maintained and driven under normal conditions. This was a spontaneous, catastrophic structural failure of a safety-critical component. I am requesting that NHTSA investigate this as a potential manufacturing defect for the 2022 Chevrolet Bolt Ev.
I have a faulty electric power steering, it prevents the steering wheel to return to center.
2022 chevy bolt, less than 10,000 miles. Problem began 11/24/23. Steering wheel locks up at low speeds, gives warning "steering assistance reduced" at higher speeds. At low speeds, steering wheel turns only a small amount before it clicks and stops. Very dangerous in tight parking lots or trying to turn left or right from a stop - takes multiple tries to get steering wheel to turn, and sometimes it jerks back in the opposite direction. Took it to dealer, they said steering column needs to be replaced. Did not have an accident or hit anything prior - I think the column is defective.