Manifold/header/muffler/tail Pipe Problems of Chevrolet C3500

Chevrolet C3500 owners have reported 2 problems related to manifold/header/muffler/tail pipe (under the engine and engine cooling category). The most recently reported issues are listed below.

1 Manifold/header/muffler/tail Pipe problem of the 2002 Chevrolet C3500

Failure Date: 08/09/2005

The contact owns 2002 Chevrolet dump truck. When he first bought it the brakes were bad. He took it back to the dealer, and they put new rotors on the front. He was still having problems with the brakes, and he took it back, and they said the brakes were fine. He took it to midas, and the back rotors were shot. They put new brakes and rotors on the back. Also, the fuel gauge sensor was defective. They replaced the sensor. The rear end was bad. They rebuilt the rear end. Then the exhaust system malfunctioned, and they put new manifolds on it.

See all problems of the 2002 Chevrolet C3500 🔎.

2 Manifold/header/muffler/tail Pipe problem of the 1999 Chevrolet C3500

Failure Date: 07/11/1999

Exhaust which is too close to floor boards gets overheated on passenger's side. This causes the passenger to put feet on dashboard due to hot floor boards. Been to dealer & informed by mechanic the problem can not be solved.

See all problems of the 1999 Chevrolet C3500 🔎.

Other Common Engine And Engine Cooling related problems of Chevrolet C3500

Problem Category	Number of Problems
Engine problems	3
Engine Cooling System problems	3
Gasoline Engine problems	2
Car Stall problems	2
Engine Knocking Noise problems	2
Diesel Engine problems	2
Manifold/header/muffler/tail Pipe problems	2
Check Engine Light On problems	1
Engine Stall problems	1
Engine Shut Off Without Warning problems	1

Switch Make:

Switch Model:

☘ C3500 Service Bulletins

⚑ C3500 Safety Recalls

☤ C3500 Defect Investigations