30 problems related to steering rack and pinion have been reported for the 1998 Chevrolet Cavalier. The most recently reported issues are listed below.
The contact owns a 1998 Chevrolet Cavalier. While driving in reverse approximately 5 mph, the contact attempted several times to turn the steering wheel but the steering wheel would not respond. The failure was a continuous occurrence in any selected gear. The contact referenced NHTSA campaign id number: 02v286000 (steering: rack and pinion) but was advised that his VIN was not included in the recall. The vehicle was neither diagnosed nor repaired for the failure. The vehicle was no longer being driven. The failure mileage was 139,000. Updated 5/24/11.
There was a recall on the steering rack and pinion on 1998 Chevrolet Cavalier build in 4-01-1997 to 10-31-1997 mine was made 11-01-1997. I know that what the problem is with mine because at times I can't turn the wheel at all when I slow down. The reason I'm writing about this is I would like to know if there been other reports on this problem with other 98 Cavaliers made at this time. I would like a report sent to general motors to see if they will go good for this part. I have a child and I feel this is a safety that they should go good for it and have it fix by a dealer and they should pay the dealer for the problem. Please email me back . You have my email address. I would like to hear back on this real soon. Thank you.
On 08. 25. 2003 sun Chevrolet (in pittsburgh, PA) performed recall work on my 1998 chevy Cavalier. This was classified as "rack and pinion campaign 02049, MA-96-v0948. 7". At that time the only part listed on my receipt as being installed on the Cavalier was bearing k 6. 835 a. Recently I have been encountering difficulty turning the steering wheel, where it feels as though the power steering has become disabled intermittently. This is very startling when it occurs, and has led to several "near misses" in traffic when trying to negotiate turns. So, on 07. 21. 2005, I took the vehicle back to sun Chevrolet for them to evaluate this problem. They told me the vehicle needs a new "steering gear" for $1168. 95, and that the vehicle is unsafe to drive. I called pricilla lundquist (from Chevrolet 866. 952. 4368 x 58092, service request # 1-351040321) on Saturday 07. 23. 2005, and she said that she would speak will sun Chevrolet then get back to us on Monday (07. 25. 2005). At that time she told us there is nothing they would do about the problem, it was completely our problem to fix and pay for. From reading the information on this rack and pinion recall, it seems as though the steering gear should have been replaced at the time of the recall (08. 25. 2003) along with the bearing to prevent this problem now. This vehicle only has about 55,000 miles on it, but is not safe to drive because of this steering problem.
Caller had same problem as mentioned in recall 02v286000 concerning rack an dpinion steering. But this vehicle was not included in recall due to VIN. Dealer and manufacturer said his vehicle was not included.
Steering: rack and pinion. At times when I come to a stop I can't turn the wheel either way it's to hard to turn. I went to a garage to see what was wrong they checked it over and they said that the steering: rack and pinion is going. This has happened to me four times so far.
The consumer stated that when she came to a complete stop, at times she was unable to steer the vehicle. She stated it happened every now and then, but it was a concern: she said she looked on the web and found that this problem was a recall. (recall # 02v286000 and campaign # 02049) she says when she took her vehicle to the mechanic she was told that the rack and pinion was going bad.
Consumer complained about rack and pinion steering problem. The manufacturer issued a recall for this problem however the consumer's vehicle was not covered under the recall due to VIN. The vehicle's steering wheel could not be turned to the left without using excessive effort.
The consumer received a recall notice (02-v-286-000) for replacement of rack and pinion bearing. The dealership the recall repair was not done properly. The problem still occurs the service manager (rick jackson).
When making a left turn at any speed steering wheel became difficult to turn. Consumer received a recall letter pertaining to this issue. Mechanic informed consumer that the recall was taken care off. However, the problem recurred. The consumer had to pay to have the rack and pinion replaced.
As listed in the may 2004 c. R. The recalls on the Chevrolet lumina, monte carlo, and malibu 97-98 on replacing the pinion bearing in power-steering gear could separate and allow pinion shaft to move. I have had the same problem on my 1998 Chevrolet Cavalier, whereas I could barely turn my steering wheel to the right while turning. My rack and pinion had to be replaced by the dealer. Why is this not included in your recall listings.
Vehicle experiencing similar malfunctions as described in recall 02049. Please review for further investigations. The consumer was informed his vehicle identification numer was not included in the recall.
Approximately 1 month after taking my '98 Cavalier in for recall 02v286000 repair I started hearing a terrible sound from the steering every time I make a left-hand turn. This noise is only heard when making left-hand turns.
Consumer took the vehicle to the dealer for recall remedy 02v286000 on 02/24/03. However on 03/20/03 consumer attempted to the turn steering wheel to the right, but the steering became very difficult as if it locked up and the wheels did not turn properly.
After the recall was performed on the rack and pinion, the problem recurred.
The steering rack and pinion locked up on two separate occasions. The vehicle was involved in recall# c02049-s. There had been four incidents while attempting to turn left in traffic. Chevrolet would not replace the rack and pinion gear assembly until the dealer could replicate the failure.
Vehicle experienced loss in steering. The vehicle experienced 4 failures when the consumer attempted to make a turn the steering failed and then the engine died. After numerous visits to the dealership, the refused to make any repairs until the vehicle was further evaluated. There was a recall regarding the steering rack and pinion in which the vehicle experienced the same symptoms. (brother on behalf of sister naida schaefer).
Nhtsa#02-v-286-000 consumer was informed the recall replacement would be performed in March or the first week in April. Scc.
Complaint of recall service co2049-s nar 07/10/2003 the consumer experienced a clicking noise when turning the steering wheel. The rack and pinion was damaged causing internal noise. The dealer was notified but refused to make repairs unless consumer paid for parts and labor. The consumer is requesting that this case be investigated and remedial action take place.
The consumer request reimbursement for repairs made to power steering. The consumer contacted Chevrolet in regard to reimbursement recall#1159156, stating that her vehicle experienced the same symptoms. The dealer denied reimbursement due to not being able to verify cause of he malfunction of the lower pinion bearing of the vehicles power steering. The rack was replaced. Scc.
Consumer was informed no parts were available regarding the rack and pinion. Recall #02 v 286 000.
The rack and pinion on my car failed as I was driving it. I had to have it replaced. Although there is a recall on the lower pinion seperation as of Jan. 2003, it only seems to cover a certain range of VIN #'s for this make. My mechanic called in Jan. Of '03, but was not able to obtain any information on it. I guess until a large number of people complain, and there are no injuries, the manufacturere does not take it seriously. I have 3 young kids, and I can not wait for a fatality for the manufacturer to acknowledge there is a problem.
I was attempting to turn left to pull out of a parallel parking space when I heard something pop and it suddenly felt as if my car had lost all power steering. One month later I heard of rack and pinion steering recall on 1998 Cavaliers which is what I drive and my car had all of the effects of what were listed. After taking my car into a chevy dealer, I was told my car did not fit the recall and that I needed a whole new transmission. I asked if they had checked my transmission fluid, and they said yes that there was plenty and that I would have to pay 1200 for a new transmission. I declined their services to fix my vehicle and later had my uncle who is an airplace mechanic take a look at it. He told me there was nothing wrong with my transmission I was just very very low on fluid. My transmission is perfect now and he agrees that my car should have been included in the recall seeing as the rack and pinion steering has broken. Repeatedly I have called gm to no avail on why my car is not included in this recall, and I feel very taken advantage of by the chevy dealer outz Chevrolet for not being honest with me about my car.
Recall campaign: steering: gear: rack and pinion (recall number 02v286000). The vehicle's rack and pinion failed prior to recall notification. The consumer contacted the manufacturer who informed him that he vehicle was not include in the recall due to VIN.
Chevrolet cavlier 1998 - the car is only 5 1/2 years old with 33,000 miles on it. I have had steering issues for more than 3 years with this car. I can not parallel park or make hard turns with out the steering locking up or forcing me to you my entire body weight to ge the wheel to move. When I've taken it to a dealership they simply say this is how the car is designed use the gas and that a recall has not been issued although according to this web page there has been. Apparantly according to gm my VIN number is not included in the Nov/2002 recall for steering rack/pinion which sounds as if it is exactly what the problem is and that there are no recalls scheduled in the future.
Consumer states while driving approximately 35-40mph, "softly" turned steering wheel to avoid an object in the road. Consumer loss complete control of vehicle's steering, travelled down an embankment and crashed into a tree. Consumer feels issue may be related to current recall 02v286000 ts.
When trying to make a turn consumer could hear noise coming from the front of vehicle while turning, the vehicle had been served twice on the rack and pinion.
I have had to have 3 major steering components replaced on my 1998 chevy cavailer and I am concerned about the future safety of the car. The rack and pinon steering has been replaced twice on vehicle to this date. My understanding from the dealership working on it they are using replacement parts instead of new parts. I have contacted the manufacture regarding this issue but no solution there. My next step is to make a complaint with MD state's attorney office.
Rack & pinion steering failed for the 4th time, causing loss of control. Would hear noises coming from front of vehicle whenever turning. Had reported problem previously. Image #855501.
The rack and pinion failed on the vehicle. 8jb.
When turning steering wheel there is a clicking noise, which comes from rack and pinion. If rack and pinion breaks their will be no steering.