Tank Assembly problems of the 2001 Chevrolet Cavalier

The contact owns a 2001 Chevrolet Cavalier. While driving approximately 65-70 mph, the vehicle stalled without warning. He was able to maneuver the vehicle off the roadway and after waiting 15-20 minutes, he as able to restart the vehicle. The vehicle was not taken for diagnosis or repairs. The failure occurred intermittently for one year. In addition, the contact stated there was an abnormal gasoline odor emitting from the vehicle. He was able to locate a recall for the failure under NHTSA campaign id number: 07e021000 (fuel system, other: storage: tank assembly: pressure relief devices) but did not confirm if his vehicle was included in the recall. The vehicle was not repaired. The failure mileage was 123,000 and the current mileage was 133,000.

At 30,000 miles I was driving up a hill with half a tank of gas, my caviler died. Towed to the servicce center and the fuel system needed to be replaced. At 45,000 miles the transmission was making noise, a grinding noise, took it in and chevolet put in a brand new transmission. It was out of warrenty so cost me alot! for a new car this is really upsetting. Most recently June, 2003 the transmission was leaking in two places, took it in again and chevolet kept it for 5 days, couldnt diagnoise the leak, assumed it was bolts on the frame of the transmission that needed replacement. Waiting now fo rthe next problem. Very unhappy with this vehicle.

Transmission rattle/noise; replaced transmission fluid, did not fix problem; gm service would not write up defect after 1st attempt: clutch assembly clutch pedal failed to release; 1st attempt was to replace clutch cyclinder line assembly, 2nd attempt was to replace clutch assembly slave cyclinder, 3rd attempt, replaced pressure plate, 4th attempt could not reproduce failure, fuel level sensor defective, replaced it and sender. Dt.