Seven problems related to fuel pump have been reported for the 2002 Chevrolet Cavalier. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2002 Chevrolet Cavalier based on all problems reported for the 2002 Cavalier.
The engine quits running while driving at highway speeds without any warning. After pulling off to the side of the road,the engine may restart immediately or after a few minutes. A technician diagnosed this as a faulty fuel pump.
The contact owns a 2002 Chevrolet Cavalier. A local mechanic advised the contact that his fuel pump failed and he was responsible for paying $500 to repair it. The dealer and manufacturer were not notified. The failure mileage was 147,000.
My 2002 chevy looks like it needs a fuel pump. 3years ago I had this same problem and the tow said it was the fuel pump and I had the fuel filter changed now since then it ran ok. I still experienced hesitation but after hearing the complains. I want to add my concern.
2002 Chevrolet Cavalier stalled without warning. Consumer states that the vehicle was not able to be restarted and was towed to a dealer. The dealer stated that the fuel pump had gone out.
Whole vehicle filled with gas fumes. Check gauges light went on and fuel gauge failed in idle. Replaced fuel pump at dealership at a cost of 770. 72.
My car is two and a half years old and has a lot of highway miles. I had 80,000 miles on the car (I have been able to log well over 220,000 miles on past cars over 5-6 years due to highway mileage). One night while driving home the "trac-off" light would come on and the car would occasionally lose speed. Eventually the trac off light stayed on the car began to die out along the side of the role. As a result I had my car towed in and the fuel pump was replaced. Total costs were well over $800. 00. I wrote to gm but was rejected on reimbursement. The fuel pump problem seems to be a common problem as I've looked at complaints the firestone auto repair center said the design/placement of the fuel pump has caused them to burn out.
Front rotors warped prematurely, about every 10000 miles. Grinding noise heard at low speeds, whether in gear or coasting & not brake related. Premature fuel pump failure, causing engine to shut off.
| Fuel Pump problems | |
| Tank Filler Pipe And Cap problems | |
| Fuel Injection problems |