Chevrolet Express 3500 owners have reported 10 engine and engine cooling related problems since 1996. Table 1 shows the 5 most common engine and engine cooling problems. The number one most common problem is related to the vehicle's engine and engine cooling (3 problems). The second most common problem is related to the vehicle's car stall (3 problems). For details of each of the problem category, use the links in the table.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems | |
| Car Stall problems | |
| Check Engine Light On problems | |
| Diesel Engine problems | |
| Engine Shut Off Without Warning problems |
The rear main seal, front harmonic seal and power steering pump shaft seal are leaking. The vehicle has 96,000 miles on it. This should not be. I took it to a shop last week to have problem fixed. Need help very expensive. Charles tomlin Read details...
The "pcm"-pump control module located on the injection pump that is in charge of operating and coordinating pump operations fails after 30,000 to 40,000 miles. This causes the vehicle to stop running--no brakes or steering similar to ignition switch problem in other vehicles. Read details...
We purchased an express van in the spring of 2006. Truck engine blew up at 6000 while driving on the freeway. In January 2014, we took the car into a dealership because it stalled 3 times. The dealership put it on the computer diagnostic device and could not find anything wrong with the van. Read details...
2002 Express 3500 6. 5 diesel van has started intermittent stalling at highway speeds 60 mph mid 09/2006. No trouble codes locked in memory. Two chevy dlrs and gm customer service made aware of pmd heat problem, but all three sources claim can't repair until major failure. Read details...
I seem to be experiencing the exact kind of ignition switch malfunction that has been the cause of the massive gm recall this year. The only problem is that the recall doesn't seem to go back to 1997. This problem has occurred numerous times since it first started to happen a week or so ago. Read details...