Three problems related to engine have been reported for the 2002 Chevrolet Malibu. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2002 Chevrolet Malibu based on all problems reported for the 2002 Malibu.
My 2002 Chevrolet Malibu shut off while driving at approximately 35 mph down an incline which leads to a rotary. All power steering and braking ability were lost. The car kept gaining speed as it drove down the incline. I had to force the car into park and use the foot emergency brake to stop it after it rolled through a stop sign and unto the rotary.
: the contact stated that the head gasket of the vehicle began to leak at approximately 13000 miles. There were no warning signs prior to the failure. Updated 07/05/06.
At 15,000 miles I had a piston knock develop. Pistons were replaced and was told this was a common problem with this engine. Gas cap seal bad at same time. Deck lid not properly adjusted at time of purchase. At 25,000 the rear left speaker was replaced due not working and the torque clutch converter was coming apart and stuck in the off position. First problem was noted in 2002.