Two problems related to suspension noise have been reported for the 2004 Chevrolet Malibu. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Chevrolet Malibu based on all problems reported for the 2004 Malibu.
: the contact stated there is a noise in the front end while turning at low speeds. The dealership determined this is the issue addressed in the technical service bulletin, manufacturer #1716682 regarding the suspension. The bulletin stated the repair is being designed and should be available in the first quarter of 2006.
The contact owns a 2004 Chevrolet Malibu maxx. While driving at low speeds, the vehicle makes a knocking noise in the front passenger side of the vehicle. The front suspension was replaced four times and the rack was replaced once. The vehicle has been taken to the shop fourteen times. The steering shaft has been packed with grease, which serves as a temporary repair. The dealer stated that the steering shaft will need to be greased approximately every three months. The speed was unknown. The current mileage was 25,000 and failure mileage was 15,000.