Five problems related to wiring have been reported for the 2006 Chevrolet Malibu. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2006 Chevrolet Malibu based on all problems reported for the 2006 Malibu.
Steering: electric power assist system steering electronic stability control vehicle speed control: cruise control exterior lighting: brake lights electrical system: wiring service brakes, hydraulic: switches: brake light steering: electric power assist system power train: automatic transmission: lever and linkage: floor shift power train: automatic transmission.
2006 Chevrolet Malibu. Consumer writes in regards to torque sensor assembly; wiring harness to the bcm or mag beam and transmission shift cable that may fracture at any time. The consumer was informed, the parts were not available.
I have been repetitively turned away by various gm dealerships to address serious issues with my vehicle & potential recalls. My issues include - steering malfunctions making the vehicle difficult to control, faulty fuel pump sending unit causing check engine light to illuminate & vehicle to stall, uncontrollable vibrations when breaking at high speeds nearly causing me to wreck, popping sounds in the suspension system, and finally unexplained electrical malfunctions such as radio switching channels on its own, failure of keyless entry system, failure of remote entry system, buzzing of lights when dimming, and flickering of headlights. I have been told by dealerships that because my vehicle is a "fleet car" that it does not qualify for any recalls. Problems began while under warranty. Steering wiring harness was replaced while under warranty. At around 65,000 miles, systems began to fail despite my regular care of the vehicle which I have documented. After warranty expired, I was routinely turned down for recall inspections. A recent emissions inspection caused concern by the mechanic over the steering of the vehicle and I was encouraged to address these problems again. I cannot afford a new car.
2006 Malibu lt power steering assist fails then resumes intermittently. Mechanic's diagnostic computer cannot communicate with vehicle computer during failure, resumes communication when assist resumes. Cannot detect faulty switches, wiring, fuses. No recall notices or service bulletins.
The contact owns a 2006 Chevrolet Malibu. The contact stated that while driving at various speeds, the brake lights would work intermittently. The contact replaced the brake lights on numerous occasions. The independent mechanic repaired the wiring harness but the failure recurred. The vehicle was taken to a dealer, who diagnosed that the bcm needed to be replaced. The vehicle was repaired under campaign number: 14v252000 (electrical system , electronic stability control, exterior lighting , service brakes, hydraulic, vehicle speed control) the remedy failed to rectify the failure. Additionally, the contact also stated that the heated seat function failed and the power steering seized intermittently. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and stated that the vehicle was not included in NHTSA campaign number: 14v153000 (steering). The approximate failure mileage was 60,000.