Engine Exhaust System problems of the 1996 Chevrolet Monte Carlo

Three problems related to engine exhaust system have been reported for the 1996 Chevrolet Monte Carlo. The most recently reported issues are listed below.

1 Engine Exhaust System problem

Failure Date: 08/15/2003

Brakes do not work during inclimate weather. Loses a quart of oil per 500 miles. Blows by smoke through exhaust when starting.

2 Engine Exhaust System problem

Failure Date: 03/01/2000

Air pump failure - second in 2 years - informed by dealer of problems "due to design defect, location allows water into air pump, this vehicle is known for this problem" but cost to consumer still $313 part coverage 12000 miles and have 14000 miles since last replacement . Dealer said they would contact Chevrolet, never heard from them, I called Chevrolet and have to mail all information to them but I have already had the repair they only waive prior to repair.

3 Engine Exhaust System problem

Failure Date: 05/29/1998

1st pump replaced under warranty. At 63,000 miles pump failed again $150 plus labor to repair.

Other Engine And Engine Cooling related problems of the 1996 Chevrolet Monte Carlo

Gasoline Engine problems	5
Manifold/header/muffler/tail Pipe problems	5
Engine Cooling System problems	4
Car Stall problems	3
Engine Exhaust System problems	3
Engine Belts And Pulleys problems	2
Engine problems	2
Vehicle Overheat problems	1
Engine Shut Off Without Warning problems	1
Engine Clicking And Tapping Noises problems	1
Check Engine Light On problems	1
Engine Stall problems	1

Switch Make:

Switch Model:

☘ Monte Carlo Service Bulletins

⚑ Monte Carlo Safety Recalls

☤ Monte Carlo Defect Investigations