Three problems related to blower have been reported for the 2005 Chevrolet Silverado 1500. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Chevrolet Silverado 1500 based on all problems reported for the 2005 Silverado 1500.
The heater blower would not turn off which drained the battery. Now both parts need to be replaced. According to Chevrolet, this part was a recall item if made from a certain manufacture. Apparently, our part was a different manufacturer which is why we didn't get the recall notice. Since our part failed, perhaps, it is a design defect or the other manufacturers were delinquent during the assembly process as well. Please investigate to see if we may qualify for a recall on this part.
2005 Chevrolet Silverado 1500. Smell from heater/a/c blower. First told blower motor. Upon closer examination found that blower motor was ok but resistor and wiring harness had melted/burned. Damage was local to harness and resistor. Dealer will not cover damage. Service bulletin exist but will not help pay.
2005 4-door chevy silverado 4x4 defroster/heater/blower and directional indicator and temp gauge in mirror fail at altitude (about 3,000 feet) only in winter driving conditions where temp. Is around 32 degrees. Dealer is at a complete loss as to the issue which is a safety issue with no "heated" air passing over the windshield to clear and defrost.
| Blower problems | |
| Visibility problems | |
| Defogger problems | |
| Wiper problems |