19 problems related to body have been reported for the 2007 Chevrolet Silverado 1500. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2007 Chevrolet Silverado 1500 based on all problems reported for the 2007 Silverado 1500.
Frame has rusted out beyond repair.
I have already replaced inner and outer rocker panels on both sides, replace complete bed 6-14-2019 and now my whole frame from the cowl needs to be replaced.
Dash cracking, fuse box continues to throw codes, front end problems.
My 2007 chevy silverado new body style the bed needed replaced with 116000 on it so when I took the bed off I noticed the frame was shot if you want more photos I know I noticed this problem in February but I didn't know I could do a complaint to you all about the safety I also contacted gm about the concern and they didn't really care about it.
Tl- the contact owns a 2007 Chevrolet silverado. The contact stated that the vehicle did not past inspections due to the frame and being unsafe to drive on the road because of rust. The vehicle was taken to an independent mechanic where the frame was patched with adhesive. The vehicle was taken back to get inspected and the contact was informed that it was not sufficient. The vehicle was not taken to a dealer for a diagnostic test or repairs. The manufacturer was not made aware of the failure. The failure mileage was 108,331. Dr.
Takata recall , was never contacted about the recall , also wheel hub assembly I have replaced them several times and I have yet to hear from anyone about this situation I don't think I will be buying a chevy any longer because of the rust on this truck and everything else that is wrong with it.
Engine burns through oil and always needs additional oil between oil changes. There is no signs of an oil leak nor is there any smoke. Also the frame of the truck is comepletely rusted.
Tl- the contact owns a 2007 Silverado 1500. The contact stated that while parked the trailer hitch broke off and separated from the vehicle. Upon inspection it was discovered that the trailer hitch had sustained severe rusting. The cause of the failure was not diagnosed or repaired. The local dealer kerry Chevrolet of alexandria, ky and the manufacturer were both notified of the failure. The VIN was not available. The failure mileage was 85,500. Jft.
The contact owns a 2007 Chevrolet Silverado 1500. The contact stated that while driving at speeds above 30 mph, the front end of the vehicle would experience severe shaking and vibrating. The contact discovered that the passenger side mounting bracket for the suspension and steering had separated from the vehicle and a sub frame had fractured near the bracket. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.
The truck frame, bed and cab are completely covered with rust. Uncertain how long the framed will be safe in order to operate the vehicle.
Tl- the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that on both the driver side and passenger side sections of the dash board had experienced multiple cracks that extended approximately 18 inches each. The contact indicated that the dash board was made of a hard plastic material. The vehicle was taken to the local dealer gent Chevrolet(2715 35th Ave, greeley CO) who indicated that the dashboard needed to be replaced. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 78,000. Jft.
Tl-the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that dashboard was fractured on both the driver and passenger side. The contact mentioned that the fracture on the passenger side extended to the air bag. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 111,000. Sms.
The paint and clear coat on the top and hood are fading.
Both rear fenders over tires are rusting thru the metal. It is not coming from the underside but thru the metal itself. Truck is well cared for, garaged, wash regular only 80,000, this seems to be a problem only with new body style 2007 gm trucks only. At this time this time gm is not willing to fix the problem.
Door acturato failed could not get out of truck had to craw out window.
My rear corner panels have completly rusted out. This started back in 2013. I went to 2 dealerships in the albany , NY area. They also said it was a known problem. Why isnt this recalled if 2 Chevrolet dealerships have said this?.
Tl- the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that the vehicle spare tire was not able to be lowered. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure via e-mail. The failure and the current mileage was 87,000. Pmb.
The dash on my 2007 chevy silverado has cracked at the corner of passenger airbag and above instrument cluster. I'm concerned that these pieces of plastic will become projectiles if the airbag deploys.
The contact owns a 2007 Chevrolet Silverado 1500. Nine months after the contact purchased the vehicle, he had it detailed. He began noticing rust spots all over the vehicle and the undercarriage. The dealer stated that the failure was due to iron deposit from the transportation rail. An acid bath to repair the vehicle would cost $400. The repair was not performed because the vehicle was still under warranty. While backing out of the driveway, the contact heard a clanking noise. He took the vehicle back to the dealer for inspection. The dealer stopped the clanking noise; however, it recurred a week later. The vehicle has been to the shop at least eight times for the same failure, but there is no remedy to satisfy the issue. The vehicle was towed to the dealer and the contact stated that he would not accept the vehicle back unless all the failures were resolved. The failure mileage was 20,386.