general problems of the 2020 Chevrolet Silverado 2500

I was traveling east bound on i26 when the bosch fuel pump exploded and sent metal shavings throughout the fuel system. It's the same pump gm has settled a class action lawsuit when I spoke to the adjuster I was told. My truck wasn't included but yet it has the bosch fuel pump the lawsuit is for cost me 10000 to repair. I have repair bill. And then I was in a accident and the air bag curtain deployed but the passenger side and driver side did not I think there's a recall on the also.

Def tank heater short causes wiring harness to melt and fault on diesel trucks, enabling limp mode. Limp mode is dangerous when hauling trailers over long distances. Faulty part is on 6 month backorder. No reparations from gm.

Service def message in truck that will soon result in reduced speed. Local and purchasing dealers both stated a new def tank is needed. A tank is not available and is on back order.

My 2020 silverado hd truck requires a replacement wiring harness and def tank and is basically inoperable. This is a known issue for gm and spans multiple model years. Gm continued to produce throughout multiple model years knowing that owners may be stranded and unable to use these vehicles because of the defective parts. Hardships for owners would include loss of income and exposure to various dangerous conditions. The def tank has a heater system that can get exposed to the def fluid because of a poor design and poor manufacturing standards resulting in short circuit. Gm will replace the wiring harness and combination tank/heater assembly under warranty. The parts are supposedly on national back order, yet gm continues to manufacture and ship new 2022 models with the required parts needed for repairs. Gm will not provide alternate transportation. Supposedly in excess of ten thousand trucks are affected. Warm climate owners and warm temperatures may affect this issue positively. Gm has no policy for a timely response to this issue. Trucks will become unsafe to operate when the electronic controls limit the truck speed to 5 mph or less. An operator may become stranded and exposed to dangerous highway conditions if stranded with this issue.

The def heater/tank shorted out. The def system has thrown a code 3 times in the little over a year I’ve owned the truck. This final time I was told that the tank needs to be replaced. The truck has now been in the shop for 2 months and there is still no ship date on the replacement tank. The tanks are on a national back order. From what I understand there are about 9,000 people waiting for this def tank countrywide. I now have a $60k work truck that I am paying for but cannot use with no reasonable end in sight.

My vehicle is less than 1 year old with about 11500 miles. My service exaust system warning light illuminated and provided a warning that my speed would be reduced in a set amount of miles. After adding additional def fluid to determine if that was the issue my car the car returned an error of service def system. This then lowered the amount of driving mileage until my car would be forced to a reduced speed. This occurred while operating the vehicle and may have resulted in damage to my vehicle or other motorist when traveling on an expressway. The dealer explained that they had other cars in for the same issue and it took over a month to get the parts in for repair. Additionally gm has provided no guidance or warning regarding the issue.

Three days after purchasing my 2020 chevy 2500 silverado, on September 28th, 2020 around 1253 I tried to start my truck and it wouldn't start. The truck turned over but seemed like it wasn't getting fuel. I then received a diagnostic alert. After changing the relay the truck ran fine. I then scheduled to take it in to the dealer on October 5,2020 to have a diagnostic done on the truck and they found nothing. The very next day it did the same thing on October 6th, 2020. I then scheduled to have it taken in again and found out that the fuel control module on several other gm vehicles where faulty on new vehicles. I had to cancel my second appointment due to the dealer wouldn't provide me with a loaner car while they worked on my truck. This vehicle is under warranty. Then again on the October 20th, 2020 the vehicle would not start. After changing out the relay switch it seemed to reset the system and starts and runs fine and the check engine light goes off. I work in emergency services and need my truck to run when I turn the key over. There's no common factor leading to this lack of turning over. And my dealer is not working with me to come to a solution to this problem. This has happened on 3 occasions at random times.