Brake Fluid Leak problems of the 2003 Chevrolet Silverado 3500

I was driving to work in the morning on 9/23/14 and went to apply the brakes to slow down, when the brake pedal went all the way to the floor. I was able to slow down while down shifting the transmission and narrowly missing hitting the vehicle in front of me. I pulled over and noticed brake fluid leaking from beneath the brake master cylinder. I purchased a large bottle of brake fluid from a gas station and continued to fill the brake reservoir until I made it back to my local auto repair facility. During the shop's investigation, they discovered that a steel brake line had burst due to rust. In further investigation they noticed that all steel brake lines needed to be replaced, because they were nearly rusted through. I authorized the repair at a cost of nearly $1000. 00. I have owned many vehicles that were much older than this truck that never had any issues with brake line rust or failure. This is a safety concern due to the sudden nature of the failure. Without any warning this could have resulted in a crash. I consider myself lucky, but if this is not addressed in this line of gm trucks someone could seriously get hurt or worse.

Thank god my husband was with me and knew what to do. I was driving. As we were going down the interstate at 65 mph we here a noise not having a clue in the world. He said we need to find a pull off and see what that could be. As I went to exit off I discovered I had no brakes. None whatsoever. As my husband gets it to a stop we discover brake fluid pouring out from behind the fuel tank and between the cab. I was panicing. My husband crawls up under it to discover all the brake lines are rusted out and busted. We purchased this vehicle the first of March 2014 from jerry (todd) hunt auto sale in lexington nc. How could he even be allowed to sell such an unsafe vehicle? that was a matter of life and death. How can Chevrolet even put such brake lines on as that? as I called Chevrolet they don't want to do anything. I called todd hunts to have the lady yelling at me! rude! that's beside the point. . . I seen death before my eyes that day. I found on consumer agency where out of 473 complaints 101 was the same issue as mine the same trucks the years 1999-2003. I also found in new york times where gm isn't wanting to do a recall cause it was going to cost millions of dollars. So now what? we all just get killed before something is done?.

Tl-the contact owns a 2003 Chevrolet Silverado 3500. The contact stated that while driving approximately 20 mph, the brake pedal was applied numerous times before the vehicle would stop. The contact was able to resume with caution. He also noticed that the brake line was ruptured and caused brake fluid to leak. The contact planned to repair the vehicle himself. The manufacturer was not notified of the problem. The approximate failure mileage was 175,000. Kj.

The contact owns a 2003 Chevrolet Silverado 3500. The contact stated that while braking to a stop, the brake pedal went to the floorboard abnormally and he was unable to engage the brakes. The contact stated that he had to shift into neutral in order to stop the vehicle. He also mentioned that after he inspected the vehicle, he noticed that the brake lines were corroded and brake fluid was leaking. The vehicle was not taken to the dealer and the manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and the current mileage was 111,000.