Table 1 shows one common structure related problems of the 2023 Chevrolet Suburban.
| Problem Category | Number of Problems |
|---|---|
| Body problems |
Sun roof exploded while driving. Temps were not extreme, there were no significant pressure changes. Sun roof had no prior damage. Looking online multiple people reported the sun roof exploding on 2023 tahoes and Suburbans.
Oem running boards, non powered. It is available for inspection. The running boards are slippery evetime they are wet. Does not matter what shoes you have. I have slipped 4 times since owned the vehicle and even broke the interior panel of my driver side door in 2023 which lead to a$500 repair bill. My wife and I both slipped today (1/26/26) and bruised pretty bad. Kids have also slipped in the past. No, it was not inspected or reproduced but dealer did say its a common problem they see with the oem running boards. No, it was not inspected by the dealer. No warning lamps since it is a non powered part.
I was driving down the road at roughly 30 mph when my fuel tank dropped. The front fuel tank strap fell off and the bolt was gone. The fuel tank drug on the road, which prompted me to stop driving. There are scrapes on the front of the fuel tank and the strap was bent. This is a huge safety concern because had the fuel tank cracked or fell off completely this could have caused a fire. Had we been traveling at higher speeds, this could have been a very serious accident. The potential for gasoline or diesel to ignite was absolutely present. It could cause a fire or even an explosion, potentially injuring occupants and causing damage to the vehicle. I was travelling with my kids and mom, so the risk of injury to multiple people was present. The manufacturers only response so far is that it was not an open recall issue so it is not covered. No warning lights came on when this happened.
The windows would go down all by themselves and not roll up . The infotainment system will flash on and off telling you to start strip all by itself. The door locks will lock you out and in not letting unlock the truck . The key fob is the only way to unlock it. I have taken it to the dealer five times to be repaired and they say gm software is not capable of finding the electrical problem. They just keep replacing parts. I filed a complaint with the state ag office and gm said they were not going to address the complaint because the vehicle was still under warranty.
Question 1) I’m experiencing bubbling under the factory paint and it’s available for inspection question 2) unknown question 3) yes question 4) yes it has been inspected by Chevrolet dealership question 5) I noticed the defects when I bought the vehicle brand new in 3/1/2023.