Two problems related to other fuel system tank filling/charging have been reported for the 2012 Chevrolet Volt. The most recently reported issues are listed below.
My 2012 Chevrolet Volt shutdown while driving with a full tank of gas when the electric battery reached zero range. The car went into neutral on the freeway at 65mph and would not move under its own power. The car would not jump start or charge. The hpcm2 has disabled charging and caused a check engine light with all 4 batteries in low Voltage lock out. This is the same problem as another recall which gm will not perform because the VIN was not included. Nhtsa campaign number: 18v397000 I have a unsafe car that is now locked out until the recall is applied but the factory will not apply the recall.
When filling the gas tank: back pressure is sensed by gas station pump and stops the flow of gas after a quick moment. Continuing these short bursts can take a long while. If trying to fuel slowly below the threshold of the back pressure being sensed by the pump, it could result in gasoline flowing and squirting out of the gas tank opening, onto: the car, tire, brakes, underside of car & the attendant filing the gas tank.
| Other Fuel System problems | |
| Other Fuel System Tank Filling/charging problems |