Two problems related to steering tie rod assembly have been reported for the 2012 Chrysler 200. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2012 Chrysler 200 based on all problems reported for the 2012 200.
Awful popping noise to front end when driving. Worsens over time . Had to shop 4 times. They now admit to a problem with tie rods at manufacture. Dealership is offering to fix with a $100 CO-pay since it is now out of warranty mileage. I am working with Chrysler to get the rest covered since it is an unresolved warranty issue.
Purchased this vehicle new off the lot April 2012. This issue I currently have became an issue for me in Feb 2014 with the winter weather I entered freeway tried to gain speed once speedometer hit 50ish noticed the car began to brake loose and sway side to side really quick and scary,immediately slowed down sensation went away could not drive above 40mph, while all traffic around me on the freeway were traveling at a much greater speeds I figured it was just by chance I hit an ice patch. I attempted to speed up and once hit 45mph the side to side sway once again was present exited the freeway and do not travel above 40 in any wet,snow,icy weather but regardless of speed if I hit anything slick I sway, the low speeds just help me maintain control of the car. My husband thought I must just need a winter tire,(there are a set of 4 goodyear eagles on it presently) until he drove it and determined there was definitely a serious issue jacked it up to reveal that it was the inner tie rods completely wiped out contributing to the sway. Contacted the dealership to resolve it(mind you the mileage was now at 37050) was told they would do an inspection for $85 and would call Chrysler to see if they would honor a repair since it is out of warranty however no guarantee that the repairs would be covered non the less a front end alignment. I could not leave my car for 3 days for diagnosis nor afford 85$ that would not even go towards the repair. I called Chrysler only to be told they can not guarantee anything nor would Chrysler consider anything until I have an inspection done that there are no discounts no courtesy inspection to be had. Bought a new car to avoid issues such as these.