Chrysler 300M owners have reported 6 gasoline fuel system related problems since 1996. Table 1 shows the 5 most common gasoline fuel system problems. The number one most common problem is related to the vehicle's gasoline fuel system (2 problems). The second most common problem is related to the vehicle's fuel hoses lines/piping and fittings (1 problem). For details of each of the problem category, use the links in the table.
| Problem Category | Number of Problems |
|---|---|
| Gasoline Fuel System problems | |
| Fuel Hoses Lines/piping And Fittings problems | |
| Fuel Pump problems | |
| Tank Assembly problems | |
| Tank Filler Pipe And Cap problems |
Dealer replaced fuel cell assy which included pump form a stock unit , replacement appeared to be satisfactory for approximately 5000 miles and it now is noisy, unknown if the pump is operating properly, only occurs after vehicle has been sitting for a period of time usually overnight weather and Read details...
Engine would not start due to faulty fuel relay, subsequent check engine indicator lamp, show faulty fuel system. To date, 4 attempts to correct problem by the manufacturer authorized servise center has not corrected faulty fuel system. Read details...
2004 Chrysler 300m. Consumer writes in regards to numerous suspension problems and repairs. The check engine light illuminated, the struts, tie rods, radiator, fuel pump, sway bar bushings, cam shaft sensor were all replaced. The struts and tie rods were replaced several times. Read details...
Reporting plastic fuel tank have punctured by running over something while traveling at highway speed of 50 mph, and caused fuel leakages, priblem occurred because fuel tank is located too close to the ground; dealer / manufacturer were notified, and unwilling to assist. Read details...
Fuel tank will overflow from filler neck when refueling , will not shut off when full. Vehicle has been taken to dealer 4 times, cannot remedy the problem. Read details...