Four problems related to underhood wiring have been reported for the 2001 Chrysler Pt Cruiser. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2001 Chrysler Pt Cruiser based on all problems reported for the 2001 Pt Cruiser.
On March 14, 2005 my vehicle was stalling and actually hopping. I was unable to drive the car and had it towed to a service facility that I have used over the past 10 years. The mechanic determined the wiring harness in my 2001 Chrysler Pt Cruiser was defective at 56000 miles. He notified me that the wires inside the harness were frayed and several bare wires were actually touching, creating a severe safecty hazard, I instructed him to replace the defective part. I did not know that the wiring harness was a warranty covered part because the manual supplied me from daimler Chrysler does not contain information about the wiring harness. I subsequently found out it was a warranty covered item under the California emissions warranty. Chrylser has refused to reimburse me for a part that was defective because I had it replaced at an a. S. E. Certified facility by a master technician. I have contacted Chrysler regarding this as a safety issue and they have refused to address this issue with me. The repair facility that I took my car to has kept the wiring harness because they believe the part was defective. I want to know if you have had other complaints about the wiring harnesses in Pt Cruisers. The wiring harness is not a moving part and without any outside influences such as moisture or excessive engine movement, which I did not have, the wiring harness should never have frayed and bare electrical wires. Please provide me with any information that I can use to convince the manufacturer of my car that a defective and potentially dangerous part was sold to me.
No summary listed for above vehicle.
Defective installation of wiring harness caused open in crank sensor wire. Harness was not properly secured which allowed chaffing on cv boot. Result was complete loss of power in high speed lane of san diego freeway, placing the driver in extreme danger of collision from rear as car was coasted to safe shoulder.
When vehicle is driven between 25-55 mph engine completely shuts down without warning. Also, when engine shuts down oil light illuminates. Dealer replaced wiring harness which did not correct the problem.