Three problems related to gasoline engine have been reported for the 2002 Chrysler Pt Cruiser. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2002 Chrysler Pt Cruiser based on all problems reported for the 2002 Pt Cruiser.
I had a very alarming incident on January 23, 2006. After filling the fuel tank and traveling approximately 20 miles I smelled a strong gasoline odor. I stopped the vehicle and looked to be sure the fuel cap was in place. It was so I attempted to re-start the engine. After several attempts the engine started but ran quite roughly. I again stopped the engine to check the source of the gasoline odor. When I looked at the rear of the vehicle gasoline was running over the edge of the fuel tank shield. I decided that the vehicle should not be started again because of the risk of fire or explosion. I had to have the vehicle towed to the dealers service center. I was told the fuel line was broken. I asked that the fuel line be saved for me. I have it and it is broken on the end.
On sep30, 2002 and Jan 31,2003, the bottom motor mount broke on our 2002 Chrysler Pt Cruiser. On oct 9, 2003, the bottom and upper motor mounts failed causing major damage to the engine compartment.
On three occasions while traveling at highway speed of 55 to 80 mph a bell alarm would go off, and within 5 minutes or less vehicle would shutdown. Vehicle been towed to dealer shop and repairs were made. But the, problem was still occurring. Feel free to provide any further information concerning this matter.