general problems of the 2004 Chrysler Town & Country

I went to turn on my headlights, and they didn't come on. All the other lights work. Parking, dash, tail, and the high beam indicator. But no headlights. Also l read that people complained about windshield washer' not working. I tried mine and they also didn't work. I see there is a recall on same problem with the 2005 - 2007 Chrysler town and country limited and they are under a recall. Mine is a 2004 t & country limited. It my mechanic has checked all the fuses and relay's and can't find anything wrong except for the lights and wind washers not working. I called my Chrysler dealership and they acted like they never heard of the problem. But that's o k with them because they don't have to drive a car without headlights.

This time I was heading down with my family from one of the highest spots at yellowstone national park. My speed was about 45 mph and two lane road with lot of turns. No other traffic in front or behind me. I turned high beams on and there we go, headlights gone. I pulled quickly fog lights on to have some lights. No other options than continue to the next place where I could pull car to side of the road. When stopped I checked if knocking ecm works but it didn't, normally it does. I released four screws and pulled ecm out. Installed my spare ecm, no lights. I installed the old ecm module back and wiggled it and lights came on. I didn't check on the spot that would I have high beams. 1 hour later when we got to cottage we rented I wanted to know what happen this time when turning high beams on. Lights gone again. This time knocking ecm module helped. I tested high beam and low beams multiple times and no issues. Loosing head light have happen with this vehicle before however the issue is that it is intermittent. I haven't found any logic how to repeat it what makes it scary / uncomfortable.

Automatic.

Driving 65 mph at highway. Turned high beam lights on and headlights stop working. Turned fog lights on to see side of the road. Reduced speed to stop vehicle. Opened hood and checked ecm / fcm by wiggling it. Started vehicle and headlights came back.

I found last night when I was about to leave from home for some home depot shopping that my headlights didn't turn on. This is low and high beams. Fog lights, corner lights and indicators work just normally.

The contact owns a 2004 Chrysler town and country. The contact stated that while reversing at 5 mph after refueling the vehicle, it stalled without warning. The vehicle was restarted. The vehicle was taken to a dealer but the failure was unable to be determined. The vehicle was not repaired but the failure recurred multiple times. The contact mentioned the last failure resulted in the vehicle being unable to be restarted. The vehicle was towed. The manufacturer was notified of the failure. The failure mileage was 144,963.

Van stalls after fillups. Lose power and control of van when accelerating onto road. Very dangerous. This is a common problem with these Mini vans. Check the internet and you will see. I am not sure what to do.

The contact owns a 2004 Chrysler town and country. The vehicle was parked when someone informed the contact that smoke was emitting from the vehicle. The contact attempting to open the door but it would not open and the alarm did not function. The fire department was called and the as the firemen broke the window to get into the vehicle, the driver side door became engulfed in flames. The fire was extinguished and the main cable cut to prevent any future fires. The fire marshall stated that "the fire was located behind the driver's seat in the b-post where electrical equipment failed causing the fire". The vehicle was towed to the local dealership where the door panel, seat belts, and driver seat were replaced. The vehicle was electrical but the dealer switched everything to manual after the fire. The contact called the manufacturer who stated that there were no related recalls for the vehicle. The failure mileage was approximately 122,000. The failure mileage was approximately 127,000.

The contact owns a 2004 Chrysler town and country. The contact stated the vehicle caught on fire while sitting idle with the engine off. The fire department was contacted and determined the fire originated from under the rear driver's side sliding door panel. The dealer came out to take pictures of the damage and the vehicle was towed. The dealer was able to repair the vehicle however; the contact was unsatisfied with the quality of the repairs. The majority of the vehicle electrical components were no longer operable, such as the power locks and windows, and the air bag warning light was illuminated on the dashboard. There were no further repairs. The failure mileage was 126,000 and the current mileage was 127,000. Updated 8/4/10 updated 08/09/jb.

The contact owns a 2004 Chrysler town and country. The contact started the vehicle was parked with the engine off when it caught fire. The fire department was able to extinguish the fire. The fire originated from the driver side sliding door panel. The vehicle was towed to an authorized dealer. The dealer replaced the panel to the door and the driver's power seat. The door and driver seat were only able to be operated manually and not automatic. The failure mileage was 124,000 and the current mileage was 130,000.

Within a few minutes of filling the fuel tank, the engine will stalls. It can happen at any speed from 0-50 mph. The engine will stall about 80% of the time after fuelling.

My 2004 Chrysler Town & Country has been in the shop 4 times for the same problem. It was for a problem Chrysler has put a bulletin out on regarding malfunction indicator lamp illumination with diagnostic codes p0300-p0306 (spark plugs). The light has come on 4 different occasions during a 7 month period. Dealer replaced spark plugs all 4 times and reprogrammed the tran module. They are giving me the excuse that I am probably just getting defective spark plugs. I have had a computer in the car that I drove with and it showed nothing to them as they tell me. They say car isn't doing anything when they drive it. After 4th repair I have brought it back after driving only a few days telling them it still is not fixed, they say it doesn't do it for them and they can't do anything else unless the light comes on again. The car bucks, surges, transmission seems to mis, car has back fired going up hill, no power going up hills or inclines, car even loses power going 55 mph plus on highways, when light does finally come on car will not let you go over 10 miles per hour, feels like it is going to stall bucks and surges. The light has not come on again yet for the 5th time but it will eventually with the same codes for the spark plugs, and again I will bring it back to have it not fixed again , by them changing the spark plugs yet again. I also saw a bulletin on this site about a creak, tick, and pop sound in steering column which I asked dealer to check when it was brought in last visit, they said it was nothing, and did nothing about it, now I see other people obviously have same problem,, not fixed. I have no clue if this is a safety hazard and what, if anything, could happen . Sway bar was replaced for noise when going over bumps, and rear window motor was defective and replaced also on this car.

While driving on 3 separate occasions vehicle stalled. Then, vehicle lost power, and all the warning lights on the dashboard came on. Dealership reprogrammed the main computer twice. Vehicle is currently at dealership for the same failure.

Chrysler has discontinued backlighting of door light switches,power door switch,power mirror switch,headlamp switch,and low line window switches. During night time driving, it's very hard to locate these switches without distracting your driving ability. Took the van into dealer to have the lights re-activated (they are there), but service department couldn't enable them. (Chrysler has a bulletin on this, #08-018-02.

My town and country has been in the repair shop approx. 11 times now. It has 20,000 miles on it. The first incident happened at about approx 3,000 miles into it, about 1 month old, it shuts off by itself. This progressivly got worse, it runs very rough and loses power while driving. The steering fluid has leaked twice, first time at 6,000 miles, approx 2-3 months old. Brakes replaced approx 15,000 squeal in belt. Odor in a/c.