NHTSA Recall 95V064000
NHTSA Campaign Id 95V064000; Date: Mar. 27, 1995
This condition can cause a hole to be burned through the air line, preventing the air compressor from delivering sufficient air pressure to the braking system reducing brake capability and increasing the potential for a vehicle accident.
Recalled Vehicles:
1994 Spartan Ic Chassis; 1995 Spartan Ic Chassis; 1994 Spartan Mountain Master; 1995 Spartan Mountain Master
Component: Electrical System:alternator/generator/regulator
Manufactured by: Spartan Motors, Inc.
Affected Units:: 1,166
Recall Summary:
When in operation, the pre-heater requires good engine ground. However, the alternators are not grounded through the case, limiting the ground for engine electrical components. The pre-heater amperage can then ground to the steel braided air compressor hose which is secured in a rubber lined clip. In some circumstances, the clip can contact the frame rail causing an arc.
How to Fix:
Dealers will install a 6 gauge ground cable between the engine and the existing starter ground cable located inside the frame rail.
Recall Notes:
System: electrical; alternator; regulator; starter. Vehicle description: motorhome chassis equipped with a 1994 or later 300 h. P. C 8. 3 cummins engine equipped with pre-heaters and a 160 amp leece neville "powerline" alternator. Note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact spartan at 1-517-543-6400, ext. 370. Also contact the national highway traffic safety administration's auto safety hotline at1-800-424-9393.
Date Owners notified by Manufacturer: May 8, 1995
Also see: