| Subject: | Non-crash engine compartment fires |
| Components covered: |
|
| Investigations Summary: | This investigation was opened on Aug. 6, 2002. It was closed on Oct. 7, 2003. odi gathered fire data from various sources and inspected subject vehicles to assess the scope and frequency of non-crash engine compartment fires caused by starter cable chafing. Odi's analysis found that most of the suspect fires occurred after the vehicle had received service repairs in the area of the subject cable. Consumer complaint data indicate that the problem experience has declined since a peak in late 2001. The most recent known event occurred in November of 2002. Kia will perform a service campaign beginning in late 2003 to inspect subject vehicles built prior to January 2000 for cable damage and will replace damaged cables as necessary. Given the declining fire rate and kiaâ¿s service campaign, further expenditure of agency resources is unjustified in this matter. The engineering analysis is therefore closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency will take further action in the future if warranted. Further details may be found in the attached closing report. |
| Vehicles Affected by this investigation: |
|
Defect investigation of panoramic sunroof breakage
Defect investigation of front axle shaft failure
Defect investigation of transmission intermediate driveshaft