| Subject: | Oversensitive air bag deployment |
| Components covered: |
|
| Investigations Summary: |
This investigation was opened on May. 23, 1997.
It was closed on Oct. 9, 1998.
Note: this investigation has resulted in
a vehicle safety recall. In may of 1997, odi upgraded to an engineering analysis with 51 complaints. Odi is now aware of 88 complaints of alleged inappropriate airbag deployments. Typical complaints allege that the airbags deployed after the vehicle hit a pot hole at between 20 and 45 mph, or that the airbags deployed while driving at between 20 or 60 mph for no apparent reason. Approximately 25 drivers alleged that they did not hit anything in the roadway. Mazda will conduct a safety recall ofall 1995 and 1996 models of the Mazda 626 and mx-6, as well as a small number of 1997 Mazda 626 models, equipped with the same sas unit. The sas unit controls the airbag systemit contains a built-in crash sensor to detect vehicle deceleration during a collision. Affected models were assembled from June 1, 1994 through September 10, 1996 and have a VIN within the following ranges: Mazda 626:1yvge22**s5300001 through 1yvge22**v5599030 Mazda mx-6: 1yvge31**s5300001 through 1yvge31**t5589965all owners will be notified of the possibility that their vehicle may experience an unnecessary airbag depoyment in certain situations. They will be instructed to bring their vehicle to a Mazda dealer to reprogram the sas unit to reduce the frequency of unnecessary deployments. |
| Vehicles Affected by this investigation: |
|
Defect investigation of air bag inflator rupture
Defect investigation of brake booster failure
Defect investigation of door latch failures due to loose screws