| Subject: | Front air brake hose interference |
| Components covered: |
|
| Investigations Summary: | This investigation was opened on Jul. 29, 2010. It was closed on Dec. 23, 2010. Odi opened this investigation based on ewr data indicating that a front air brake hose could rub the tire and eventually develop an air leak. Volvo's ir response and odi's investigative review revealed no sudden "loss of air" events. Rather abrasion of the hose was being noted. Additionally no crashes or injuries were reported. An analysis of the warranty data with respect to time in service and miles to failure did not indicate that the subject vehicles were experiencing failures at a rate higher than peer vehicles. The subject vehicles are commercial vehicles. The front air brake hoses are easily visible and accessible during routine inspections. The failure mode is a slow abrasive process that occurs over time. Odi's review indicates that it is unlikely that the alleged defect would go undetected. Additionally, Volvo has issued two notices to dealers and authorized service stations alerting them to look for the alleged defect (abrasion on the air hose) in the subject vehicles. A safety related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves the right to take further action if warranted by the circumstances. |
| Vehicles Affected by this investigation: |
|
Defect investigation of windshield wiper failures
Defect investigation of volvo sleeper glass de-bonding