Other Fuel System Tank Filling/charging problems of the 2007 Dodge Caravan

After filling up my gas tank I drove away from the fuel place, and I was at a green light making a left turn and during the left turn my van stalled!! another time after this, directly after filling up gas I was idling at a red light not far from where I fueled up, when my van surged forward! this is apparently an "extended warranty" up to the 2005 Dodge Caravan for a faulty vapour/liquid separator valve that is built into the gas tank. I contacted Dodge and they said that because my van was a 2007 not a 2005 that they couldn't recall it. This is so extremely dangerous and unbelievable that they won't extend this warranty. Had someone been coming when I was turning left and my van stalled I would've been t-boned. All of this occurred on a city street.

Everytime we fill up the car it stalls and dies when you drive away. The problem only happens when you fill up the car. The scariest time it cut out and stalled we had just filled up. We were at a stoplight turning left. You have to yield to the oncoming traffic (which has the right of way) which is traveling 55 mph. We pulled out to turn left the car died. And the oncoming traffic had to lock up there brakes and swerve to avoid hitting my family and I. We have been filling only half way up in gas tank around town. Which is really annoying. We just took a road trip and it was necessary to fill up all the way to make sure we had enough gas in between towns. We would have to get gas only were we could easily hop on and off the freeway. It would die as we pull out of the gas station. I would restart and drive away. It would than be fine on freeway. Once up to speed. This is a huge safety issue for obvious reasons. I hope that someone will figure out the root cause of this issue and no one gets injured from it. I called Dodge who said they had no reported issues of this problem. Please get to the bottom of this ASAP before someone gets hurt.

After filling up at gas station (dte showed 68mi) pulled onto street - engine sputtered and would hardly run. Next fillup - approximately 2 weeks later about same dte drove about 1/2 mile and vehicle stalled and difficult to get started. Very dangerous -to be in traffic and stall. Have read online - am not the only one this is happening to - something with a part in the gas tank that is not able to be replaced -only solution reported was to replace gas tank. Looks like this is issue on other Dodge products - sounds like design flaw - whatever it is it is very stressful for an older person driving in a high traffic area.

Vehicle sputters and stalls after filling tank with gas. This only happens when filling the tank full. It happens so frequently that we only fill up at gas stations that are off of side streets. That way when it stalls it's not in a main intersection. My mechanic said he has to replace the whole tank to fix the problem and said it's quite common. It's roughly $1000 in part's and labor.