general problems of the 2006 Dodge Durango - part 1

Tl the contact owns a 2006 Dodge Durango. The contact stated that while refueling, the check engine warning light illuminated. The contact stated that fuel starting to spill from the filler neck. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the fuel check valve failed and needed to be replaced. The vehicle was not repaired. The failure recurred multiple times. Chrysler Dodge Jeep of paramus (315 route 4 west, paramus, NJ 07652) was contacted and informed the contact that there were no recalls on the VIN. The contact referenced TSB number: 10128990 as a possible solution to the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

There have been 2 recalls to date on the model year 2005 Durango, 44,951 all together. With my 2006 Dodge Durango, fuel sprays out of the fill tube because of a check valve that has already been recalled two different times. No warnings, no letters to the owners of the Durango now to advise them to use caution. Please open an investigation now and have this serious safety issue corrected for all of the Durango owners on the road today. This is a serious safety concnern. The problem has already been identified in earlier models, and there seems to be significant issues with the 2006 models as well.

When fueling vehicle, a large amount of gas overflowed filler tube after pump shutoff. Gas sprayed approximately 3 feet, covering fueler and pump.

When I go to the gas station to put gas in I can only put a 1. 50 in and the pump kick off and gas come out I wait for a little bite and it will take 2. 00 and tit does the same thing again it come right back out.

There is a known issue of fuel overflow with 2nd generation Dodge Durango that Dodge refuses to issue a safety recall to fix. At the conclusion of refueling approximately 0. 25 gal will gurgle to forcefully eject itself from the fuel filler neck of the Durango. Spilling fuel every fill up is a personal safety and environmental poluttion concern which needs to be addressed. . Read more...

Was filling up 06 Dodge Durango and fuel will flow out violently after the fuel nozzle shut off was activated. There was about quart or more fuel splashed out of the fuel nozzle of the car. There is even a rust spot on the driver side rear quarter panel under the fuel nozzle on the car where fuel has eating at the metal. This is a very dangerous stituation and can be deadly. This should be taken seriously.

My 2006 Dodge Durango slt over fills every time it is filled up. Gas will shoot out 12-15 inches in all directions sometimes. This started happening at around 60 thousand miles.

Went to fill Durango up two days after purchased used. The pump shut off automatically and sprayed approx. One liter of gas on my hand, sleeve, right leg, right shoe, and the fender/bumper of the vehicle. This is a serious safety concern and there is no warning from Dodge that this may occur. This was a recall on 2005's and Dodge representatives told me when I asked about an assist, "if it was a recall before and isn't now, the issues would have been addressed on the assembly line". This statement, from my case manager, is clearly not true. There are several videos on youtube. Com of this happening to vehicles with VIN numbers that are post recall.

The contact owns a 2006 Dodge Durango. The contact stated that fuel would spill out from the filler neck whenever the vehicle was refueled to capacity. The failure had not been diagnosed or repaired. The dealer was made aware of the constant failure. The manufacturer was not notified. The approximate failure mileage was 93,000.

I have a 5. 7 hemi and the problem just started with fuel splashing out after a fill up, pump clicks off, remove the fuel nozel and out of the vehicle fuel fill gas shoots out and all over. Maybe a pint or quart of gas, hard to measure when it's all over you, the ground and car. . . . . I also called my Dodge dealer and my VIN was not part of the recall.

Bought 2006 Dodge Durango used and pulled out of dealership to get gas and filled up and gas shot everywhere. Very dangerous and fire hazard. Problem filling ever time I get gas. A problem that needs immediate attention before someone gets hurt.

After filling vehicle with fuel gas will shoot out of intake area. Approximately 1/4 to 1/2 gallon.

When filling the vehicle up with gas, the sensor to stop the gas pump does not work. Result is an overflow of about . 5 gallon of gas to spill on the exterior of the vehical and ground below.

While filling up my vehicle with fuel, the vehicle topped off and shut off the fuel nozzel, then fuel came rushing out of the vehicle's filler tube onto the vehicle, my hand and leg, and the ground. This is an ongoing mishap with this vehicle and other 2006 Durango's as indicated by reviewign historical events on this website. It should not take a major mishap or fire to get the appropriate attention this deserves,. Chrysler refises to acknowledge there is an issue, however the 2005 Durango was recalled for the same exact problem.

Gasoline sprays out all over ground and vehicle when filling up. After pump automatically shuts off, you can hear the gasoline suck back up and than it sprays out.

While re-fueling the vehicle after the pump auto shut off clicks off about a second or two later fuel comes spewing out under pressure, spilling fuel all over the quarter panel and bumper, and onto the ground, spilling approximately a gallon or so. It appears there are several issues on this from searching online, I just purchased this vehicle used about 3 months ago.

Each time I refuel my 2006 Dodge Durango limited, gasoline spews back from the fill nozzle onto the vehicle and ground. The last time this occurred, gasoline was splashed on an individual fueling his vehicle on the other side of the pump, ruining his jeans.

The contact owns a 2006 Dodge Durango. The contact stated that while refueling the vehicle, fuel spewed back out from the filler neck. The vehicle was not taken to the dealer for repairs of diagnosis. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and current mileage was 83,000.

I just purchased a used 2006 Dodge Durango. Everytime I fill it up with gasoline, when it gets full, gasoline overflows from the filler tube and gets on the ground and me. I have read on Dodge forums that this a common problem among Durango owners and I feel is a safety issue.

I have a 2006 Dodge Durango limited with the 5. 7l motor. Every time I fill up with gas it spews out excess gasoline. This happens at any gas station. The vehicle has 72,500 miles on it and this problem has occured for the last 12,000 miles. I have contacted various dealers and I go thru the same routine: VIN reference, then they proceed to tell me it is not covered under lifetime powertrain warranty, and that they have never heard of the issue, and to contact Dodge corporate for assistance. When I contact corporate I follow the steps and they always tell me they cannot assist me at that time. I can never talk to a real person. I have a family and I do not want a fire leading to my families endangerment.

Every time I refuel my 2006 Dodge Durango (limited), at least half a gallon of gasoline spews back from the fill nozzle and onto the side of the SUV and ground (and sometimes myself or my wife). This is our family vehicle, and I consider this very dangerous for both my wife and I and our children. This is a hazard that needs to be addressed. I can provide video proof that this is a problem.

When filling up my 2006 Dodge Durango with gasoline, just after the pump clicks off a large amount of gas will spew out from the filler entrance. This has happened at different gas stations. This started happening about a year ago.

The contact owns a 2006 Dodge Durango. The contact stated that as the vehicle was refueled to maximum capacity, fuel spilled back out from the filler neck abnormally. The vehicle was not taken to the dealer for diagnostics or repairs. The approximate failure mileage was 80,000.

Each time I refuel my 2006 Dodge Durango, fuel spills out the filler neck and and onto the ground. I have to warn the pump attendant that fuel will spill out on them if they are standing nearby. If my window is down the vehicle will fill up with gasoline fumes. Our children have complained about the fumes in the back of the vehicle after leaving the gas station. The puddle from the spilled gasoline on the ground is ab out 1. 5 to 2. 5 feet in diameter.

I have a 2006 Dodge Durango. The last 5 times I've filled it up, the gas has overflowed even though the auto shut-off clicked on the pump handle. The first time I thought it must be the pump, but now that it's happened 2 more times, I'm am very worried and would like this fixed by Dodge. My vehicle is not on the recall list but is doing the same as the ones that have been recalled.

While fueling my 2006 Dodge Durango limited last night, the fueling nozzle clicked off at 19. 6 gallons and then approximately 1/4 gallon of gas spilled back out of the fueling inlet of the vehicle getting on my hand, feet, car and ground. This is the 6th time in a row this has happened and at different gast stations. I have contacted Dodge who refuse to accept the vehicle is the problem, and refuse to admit other owners are having the same issue.

When filling 2006 Durango with fuel the fuel will spew back out of filler.

Fuel spit-back- whether we fill it on the lowest setting on the gas pump or if we manually fill it using as little pressure as possible it overfills every single time and gas pours from the fill spout down the body of the vehicle, on my hands clothes and on the ground. I have had to go home and change clothes after trying to fill the car with gas.

The contact owns a 2006 Dodge Durango. The contact stated that when he attempted to add more than a half gallon of fuel to the vehicle it would spill onto the ground. The dealer advised the contact that his vehicle was not included in any recalls. The manufacturer was aware of the failure. The vehicle was taken to a private mechanic who inspected the vehicle and informed the contact of the repairs; however, the contact was unable to provide that information. No repairs were performed. The current mileage was 62,347. The approximate failure mileage was 59,800.

The contact owns a 2006 Dodge Durango. The contact stated that after refueling and removing the nozzle, fuel started to spill out from the filler neck. The vehicle was taken to an authorized dealer, who diagnosed that the valve was defective and needed to be replaced. The vehicle was repaired, but the failure continued. The manufacturer was made aware of the failure, but offered no assistance and referred the contact to NHTSA. The failure mileage was 45,000 and the current mileage was 68,835.

I have a 2006 Dodge Durango. Everytime I fuel the vehicle gas spills from the filler neck when it nears the full point. This will happen whether I am running the pump by hand or whether I have the pump in auto fill. I have tried several differnt gas stations also. If you are not paying attention fuel comes out with enough pressure to cover a person from the knee area down. Not only am I covered in gas but the outside of the vehicle and the ground below are also. The inside of the vehicle has a very strong gas odor. I feel like this creates a huge safety concern for myself, my children, and the next person to pull up to that pump that now has gas on his tires and shoes. All it would take would be a small ignition source to have a serious accident. I have checked with Dodge and there is no recall covering this issue for my year model. This seems to be very common on Durangos between the 2005-2007 years. The 2005 year has been identified as a defect for recall. Why haven't they realized all of the years are?.

At the end of refueling the vehicle will have a burst of gasoline that sprays out of the fuel neck and soaks the side of the vehicle as well as the ground and the person refueling if they are standing next to the vehicle. Same as recall campaign for the year prior (05v034000).

2006 Dodge Durango, sprays fuel out of fill port onto the ground, when it should be clicking the nozzle off.

I have a 2006 Dodge Durango limited which upon filling with gasoline will overflow instead of cutting off when full. The fuel will shoot out of the opening on the vehicle causing a potential fire hazard. This has been happening now for awhile.

The contact owns a 2006 Dodge Durango. The contact stated that after refueling the vehicle, gasoline fuel would spew back out from the filler tube spilling onto the contact and the ground. The dealer advised that there were no recalls on the vehicle. The manufacturer was contacted and confirmed there were no recalls on the vehicle. No assistance was offered. The failure mileage was 58,000.