Tank Assembly problems of the 1997 Dodge Grand Caravan

Ten problems related to tank assembly have been reported for the 1997 Dodge Grand Caravan. The most recently reported issues are listed below.

1 Tank Assembly problem

Failure Date: 01/18/2005

Heavy fuel vapors in passenger compartment, and under hood. Occurred during normal driving. Has occurred in the past but then went away the next day. All occurrences were during cold weather (20-30f). Driver and passengers experienced nausea. Mechanic said that the fuel tank rollover valve is malfunctioning allowing fuel into the vapor canister. This sounds alot like the recall for 1996 models of this van.

2 Tank Assembly problem

Failure Date: 12/26/2001

This vehicle is experiencing same problem as mentioned in recall 00-v-268-00. But vehicle is not included in recall due to VIN. Vehicle leaked out almost instantly 28 gallons of fuel. Contacted dealer, and the dealer was taking a look at the problem.

3 Tank Assembly problem

Failure Date: 05/29/2001

While pumping fuel into vehicle sliding door has came back and broke fuel cover door,knocking handle out of tank, and out of consumer's hand. Some of the fuel spilled onto consumer. Dealer was notified, and unwilling to assist. Provide any further information.

4 Tank Assembly problem

Failure Date: 10/25/2000

While consumer pulled into a school driveway to let out his child, fuel tank completly dropped off underneath the vehicle. Dealer notified, and repairs being made at consumer's cost.

5 Tank Assembly problem

Failure Date: 08/08/1997

The fuel tank cracked, causing a fuel leak, which if ignited may cause a fire. Dealer replaced fuel tank 2 times. Cause unknown. Dealer cannot determine problem. Please provide details.

6 Tank Assembly problem

Failure Date: 07/11/1997

Fuel leaks from upper right side of tank when fuel tank is full.

7 Tank Assembly problem

Failure Date: 06/15/1997

Fuel tank: fuel tank leaks when it is full, it does not leak when it is not completely full. Check engine light comes on and stays. Dealer has replaced fuel pump on gas tank, and the they also replaced the fuel injector pump on the engine . The problem is still there. The are going to replace the entire tank assembly.

8 Tank Assembly problem

Failure Date: 06/09/1997

Fuel sending unit gasket of fuel tank leaking.

9 Tank Assembly problem

Failure Date: 05/23/1997

Flames coming out of gas tank.

10 Tank Assembly problem

When accelerating fuel tank shifts against vehicle frame, causing load thumping noises when slightly less than a full tank of fuel. Dealer applied padding kit, problem persists.


Other Gasoline Fuel System related problems of the 1997 Dodge Grand Caravan


Safety Ratings of Grand Caravan Cars
Fuel Economy of Grand Caravan Vehicles
Grand Caravan Service Bulletins
Grand Caravan Safety Recalls
Grand Caravan Defect Investigations