Table 1 shows one common steering related problems of the 1998 Dodge Ram Van.
| Problem Category | Number of Problems |
|---|---|
| Steering problems |
Some Dodge Ram Vans have a latent defect in the frame that is very dangerous. As far as I can tell, there is no recall even though the internet is littered with complaints, incidents and accidents due to failure of the frame in one spot. I believe that the ac runoff is vented directly into the frame which, over time results in the eventual failure of the frame at the point where the suspension and steering are located - this results in loss of control of the vehicle. There is no easy way to correct this problem short of replacing the whole frame. Dodge denies that this is a problem and blames this defect on road salt and conditions. This would be a valid assertion if the rest of the vehicle had rot problems elsewhere on the vehicle. Including the much more volatile body parts, which are in some cases, still solid and in good condition. This problem is prevalent in several years of this model truck. This problem is easy to check for and needs to be addressed by Dodge simply because the vans are getting older and this problem will be occurring more frequently.
While backing out of my parking space and turning the steering wheel I heard a loud pop/thump. Subsequently while driving down the road at 15mph the steering went out and the vehicle was uncontrollable. I had the vehicle towed to a repair shop. The cause of the break down was the front passenger side frame had rusted and cracked. This is where the steering is connected to. No repair was possible. I have contacted alternate repair sources of dealers, body shops, welders and metal fabricators without any success to get anyone willing or able to repair the frame. The vehicle is considered non-drivable and non-fixable.
The contact owns a 1998 Dodge Ram Van. While pulling into a parking space at an unknown speed, the contact felt a hard vibration and heard a loud bang. He exited the vehicle to locate the origin of the sound, but was unsuccessful. He re-entered the vehicle to continue to park when another loud sound occurred. The steering did not respond. He exited the vehicle again and located a failure with the steering control arm and its components. The contact also noticed that the entire front end was completely rusted. He called a tow truck and had the vehicle towed to a local dealer. The dealer stated that there body shop would not repair the vehicle because they did not want to be responsible for any liability. They further stated that they may be able to locate a collision repair shop to perform the repair work. The contact has not yet been able to locate a shop to perform the needed repairs. The vehicle is currently at the dealer. The failure and current mileages were 140,000.