Headlights Problems of Dodge Sprinter

Tl- the contact owns a 2005 Dodge Sprinter. The contact stated that both headlight bulbs had gone out upon activation. The contact had taken the vehicle to an independent mechanic who was able to replace the headlights. The contact stated that soon after the initial replacement, the headlights had gone out yet again. This time,the contact had decided to replace the headlights himself and discovered burnt wiring in both headlight manifolds which he linked to the repeated failure. After the contact replaced both headlights, the contact stated that the passenger headlight had gone out yet again. The manufacturer had been notified of the failure where they informed him that there were no recalls on the vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 200,000. Jo.

See all problems of the 2005 Dodge Sprinter 🔎.

The next time our headlights failed was about 30,000 miles later. The brights still worked and also the running lights but the regular hl did not. On interstates this was not too much trouble but I'm sure we were an aggravation to a few drivers coming our way. We went to a Dodge dealer (camped in his driveway) and asked for troubleshooting the next morning. They found no problem, but again, the next night, we had the same problem, before we got home to NW florida where our local dealer again found no problem. I think there is an inadequate ground to the main headlight circuit. There are separate fuses for the headlights, running lights and bright lights, on each side of the vehicle (6 in all). The fuses are all alright. When I check the lights in our driveway they seem to work fine now. . . .

See all problems of the 2006 Dodge Sprinter 🔎.

The contact owns a 2007 Dodge Sprinter. While parked, the contact noticed that the passenger side headlight was not illuminating. The vehicle was taken to the dealer where the technician advised that the voltage caused the headlight to fail and the headlight assembly would have to be replaced. The vehicle was repaired but the failure recurred. The approximate failure mileage was 50,000.

See all problems of the 2007 Dodge Sprinter 🔎.

The contact owns a 2007 Dodge Sprinter. While parked, the contact noticed that the passenger side headlight was not illuminating. The vehicle was taken to the dealer where the technician advised that the voltage caused the headlight to fail and the headlight assembly would have to be replaced. The vehicle was repaired but the failure recurred. The approximate failure mileage was 50,000. Updated 01/04/bf the consumer stated the failure occurred twice. Updated 01/09/12.