Wiring Problems of Dodge Sprinter

Tl- the contact owns a 2005 Dodge Sprinter. The contact stated that both headlight bulbs had gone out upon activation. The contact had taken the vehicle to an independent mechanic who was able to replace the headlights. The contact stated that soon after the initial replacement, the headlights had gone out yet again. This time,the contact had decided to replace the headlights himself and discovered burnt wiring in both headlight manifolds which he linked to the repeated failure. After the contact replaced both headlights, the contact stated that the passenger headlight had gone out yet again. The manufacturer had been notified of the failure where they informed him that there were no recalls on the vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 200,000. Jo.

See all problems of the 2005 Dodge Sprinter 🔎.

While in motion the vehicles wiper motor stopped working. After further inspection it was determined that the main wiring harness had failed and several electrical conductors had melted away their protective coating causing several systems to short out and stop working. This also caused the wiper motor to prematurely fail. Wiper motor was replaced hoping that it would still work after the exposed wiring was cut back and new wiring was spliced in. However the wiring harness continued to wear down and the wiper motor electrical circuit has completely shorted out.

See all problems of the 2007 Dodge Sprinter 🔎.

My service tech started this van and went back into the house to get his cup of coffee. When he came out of the house he found the van on fire under the hood of the drivers side. The van was towed to tomball Dodge. The fire was determined to have started in the left side head light, causing severe damage to the wiring, hood, fender, bumper, mirror, insulation and much more. Dodge has not taken any responsibility and after 4 months being repaired and at a cost of $12,763. 50. I have four other Sprinters in my fleet, and I am very concerned. I think with the numerous electrical problems that Sprinters have had, this was one that they should have taken care of.

2007 Dodge ram pick up truck long horn ,I was going to work on the highway and my back right door caught on fire, I pulled over and the truck was full of fire and smoke, I put it out with my shirt and poured water on it.

Repeated electrical problems. Headlights taillights etc. Dealer states it is fuses & bulbs. Vehicle checked by automotive electrician and fuses bulbs etc ok. Possible defective wiring. Have made numerous (5) attempts to correct. Relative also owns similar vehicle with same problems.

See all problems of the 2006 Dodge Sprinter 🔎.

2004 Dodge Sprinter fuel hose disconnected which caused the engine to stop operating while in motion. There was also a wiring issue which caused the battery to drain and the engine fault light was illuminated due to the loose connection in the fuel tank.

See all problems of the 2004 Dodge Sprinter 🔎.