Automatic Emergency Braking problems of the 2022 Ford Bronco

I own a 2022 Ford Bronco. My vehicle has an electronic brake booster failure that causes multiple warning messages, brake system faults, and loss or reduction of brake assist. When this happens, the vehicle also prevents the 4-wheel drive system from engaging or switching modes. This is especially dangerous during winter conditions. When driving in snow or slippery conditions, I am unable to engage 4wd when it is needed most, while also experiencing brake system warnings. The vehicle becomes difficult to control and does not feel safe to drive. The dealership confirmed this is a known issue affecting multiple Ford Broncos and that the electronic brake booster part is currently back-ordered and unavailable. I was told many vehicles are affected, yet there is no recall for the 2022 model year, even though newer model years have a recall for the same component. This issue creates a serious safety risk due to impaired braking performance and inability to use 4-wheel drive in hazardous conditions. The vehicle had to be parked due to safety concerns. And the he issue happens intermittently, making it unpredictable.

When my brakes are cold and I stop on a hill. . . The brakes do not hold and the car moves about a foot forward. Then something kicks in and it jerks the car to a stop (all the while my foot is completely pressed down on the brake. No warning lamps, no lights, nothing. . . Just rolls when brake is completely applied. It only does this when the brakes are cold. After they warm up it doesn't do it anymore. The dealer has looked at it and couldn't replicate (because the brakes weren't cold) and told me to bring it back if it happens again. It happens every morning but by the time the dealer gets it it doesn't do it anymore. A plethora of Bronco owners are experiencing this same thing. Our thread on [xxx] is full of people experiencing the same thing. Some guy in canada said he had every brake part replaced and it still happened. Then they did some sort of software update and he hasn't experienced it since. Why is this update not available to all? this is a serious hazard! someone is going to get hurt! information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

On June 13, 2025 my 2022 Ford Bronco and was involved in a serious collision in which the airbags did not deploy, the emergency braking and forward collision warning did not activate either. The second vehicle was t-boned at an estimated speed at the point of impact was 45mph. Both vehicles were a total loss. The Bronco suffered a bent frame and the passenger door would not open. The repair estimate was in excess of $36,000. I have reported the concern to Ford motor company under case number cxh-04933824-c1c3g9. At the time of the accident, there were no open recalls, warnings or notifications affecting the airbags or other safety systems. The vehicle was as-delivered by Ford from the factory with all regular service conducted by the local Ford dealership.

Claim # cas cxh-026-40233- pre- collision assist(pca) to whom it may concern please forward to customer services since they refused email. We have a 2024 in route to riverhead Ford and refuse to pay their $200 diagnosis fee on pca failure. Not in obd iii plug in diagnosis no way to check if functioning. Will be reported to NHTSA. My Broncos 2022 is still in bumper to plumber warrantee but recently with my key not administrator key noticed the pca was not functioning. On page 24 Bronco quick reference guide states in pertinent parts: " if your vehicle is rapidly approaching a stationary vehicle, vehicle traveling in the same direction as yours or a pedestrian within your driving path, the system is designed to provide three levels of functionality. Alert; brake support & active braking" while driving an speaking to a customer service agents I tested behind a benz at approximate 40 mph and deliberately move my Broncos my22 less that one car length or so. Nada! no display! to place a pedestrian in from to test the pca would be wrong. The limited express warrantee state no charge for warrantee service, yet a call to riverhead Ford service agent who stated a diagnosis charge of $200 or so for one hour. The warrantee also states that power up on line modem saves are updates are no charge. Ford three customer service read " non-warrantee" Ford policy , but refused to disclose where they found that statement in warrantee . ( attached download) further two supervisors read same "non-warrantee" Ford statement said I must pay $200 or more for electronic software/radar type rf signaling systems like proximity sensors for diagnosis purposes. A simple drive with a car in front should when switch by touch screen from high ,moderate or low should function and save lives. It failed that test. Previously, the system function ,when a driver cut dangerous in front of me and if function on screen and I immediately braked, no so today. A non- Ford check the display a.

Break pedal feels very mushy and no breaking effect , very dangerous on highway speed for my car and cars behind me. I went to different dealers for a fix ,they all says it is normal, but it is sure not normal, I had multiple close calls. Break feel is inconsistent everyday. When I apply the break lots of deadline and no breaking effect for first few inches also pedal sinking to floor, Ford and dealership are ignoring this serious safety concern. Kindly do the needful,thank you.

Bronco my 2022 owners manual pages 288-289 on SUV shows how to disengage in features menu the background esc controls for yaw in the trailer sway subsystem of esc. When a dangerious highway sway of a trailer occurs, this subsystem will detect yaw and apply brakes. It is reported on f150 that rear brakes will heat up and may fail. Base Bronco, for marketing purposes cannot be factory equipped tow package options, but accessories market tow hitch and electric harness. Big ben and others model may or may not have option. Cas38178902 was open and selling dealer has been advised. If brake start to heat up and seaze pads to rotors the base Bronco has no method to disable the trailer sway controls since the map factory was instructed not to enable the trailer tow control. Jackknifing may occur on base Bronco with afterfactory tow equipment.