Table 1 shows one common service brakes related problems of the 2025 Ford Bronco.
| Problem Category | Number of Problems |
|---|---|
| Service Brakes problems |
Flat towing a 2025 Bronco behind a 2025 newmar dutchstar using a blue ox tow bar with demco airforce braking system. Ford has a setting called neutral towing. It allows you to tow behind a motorhome with brake lights, braking, etc. When the Ford is in neutral tow, and in neutral gear, all 4 wheel roll freely and you can tow safely. What's happening is the Ford is waking up out of neutral tow when the 12v battery gets low. This isn't supposed to happen as there is a 7 pin electrical connector from the motorhome to the 6 pin electrical connected to the Bronco. Once the 12v battery gets low, the Ford computer wakes up, see's it moving the back tow tires, so the system is applying the emergency brake locking up the 2 back tires. This has now happened three times as we have traveled from [xxx] to [xxx] (had it looked at crossroads of Ford of apex where I bought it). I took it in to schmop Ford in denver and after almost a deadly accident on xxx near [xxx], to xxx. They found the back two tires destroyed. Ford replaced the tires at no charge, but the issue remains. This SUV should not be approved for flat towing. It is dangerous and could be deadly. You have no way of knowing unless someone else tells you. Thanks to the stranger on xxx on xxx. They told us of our issue so we pulled over. If we were to continue driving the motorhome, the tires would've been totally destroyed, a fire, or cause us to flip over. There are so many complaints on the internet about this issue. You must make Ford fix this issue with a software fix immediately. Don't make my complaint for another unlucky traveler like myself. I have enclosed the back tire picture. You can see one tire with the tread completely gone, the other tire tread missing is not shown. You can also see how the tires are mis-shaped from rubbing across the highway cement. I am trying to upload pictures but your system is giving me an error for a jpeg less than 10mb information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
Its becoming more frequent and a huge safety issue. When you're driving the car, it feels like the emergency parking brake automatically engages. And when you push the brake pedal, it almost feels like it's dead, meaning there's no pressure back against your foot, which is really unusual for this vehicle, period. You don't necessarily lose control of the car, but you certainly don't have complete control of the braking system, period. Then you are in a period of time to get off the road safely and turn the vehicle off and restart it. Then the system seems to correct itself, and you can drive away. But I'm concerned about this from a safety perspective,.
Sunday April 19 2026, in a drive thru while stopped, the following alerts popped up with their corresponding dash lights: check brake system park brake limited service function pre-collision assist not available service advance track brake pedal lost vacuum / pressure and became hard. Brake would not engage and needed to use electric park brake to stop vehicle. Got out of the drive thru and into an empty parking lot. I tried accelerating and then stopping but vehicle would not stop while pressing the brake. Used e brake again to stop. I turned vehicle off and back on. All errors did not pop up again and there were no lights on the dash. While driving home less then a mile from original incident location, the same errors and brake failure occurred while going 30+ miles per hour. Same issue with a hard brake pedal occurred. This time, if brake pedal was depressed far enough, the e brake would engage but only the rear wheels would lock up and vehicle would skid/slide in order to slow down. I have video recordings of these incidents. Brake system failed as vehicle lost ability to brake at low and high speeds. The loss of brakes could result in a car crash and deaths. The vehicle has been towed to a Ford dealer and they are in possession of the vehicle. They are currently investigating the issue. The vehicle has not been inspected by manufacturer or authority agency. There were no warning lamps, messages, or symptoms prior to the brake system failing. The brakes worked normally and then suddenly failed.
I have experienced three total brake failures in my 2025 Ford Bronco. During the most recent incident on 2-18-2026 the brake pedal traveled completely to the floorboard, requiring extreme force and multiple pumps to stop the vehicle. This appears to be the exact failure described in Ford recall 25s77 (NHTSA campaign 25v488) regarding the electronic brake booster (ebb) module. The vehicle was presented to suntrup Ford twice previously for this issue, but the defect was not corrected. I am reporting a life-threatening safety failure. After February 18th 2026 brake failure I had Bronco towed to suntrup Ford in kirkwood missouri and that's where it will stay. I am too frightened to drive it again.
Loss of braking. Note weather was cold in single digits fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to slippery/4a mode. After about 5 minutes inside I pulled out and switched back to normal/2h mode. Less than half a mile later I got multiple warnings that the brakes, ebb, collision detect, and abs had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine braking with my manual transmission to get to off the road to a parking lot, although I did also receive a parking brake overheat fault the turn before getting into the parking lot. I shut the vehicle off without the parking brake on. I turned it back on and the dash warning lights all disappeared after a few seconds. Brake function returned and I drove it to a Ford service center about 1 mile away. They were not able to reproduce the problem or find any dtcs. I did get notifications of some of the faults to my Ford app on my phone. I am uploading the redacted ro and screenshots of the Ford notifications. Losing braking obviously put myself and my passenger pregnant wife at risk. Thankfully I was moving at lower speeds on a flat section of road and not taking a highway exit at the time of failure.
On Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the Bronco to smash into the exterior of my home garage area. Then, shifting to drive, the vehicle again lurched, uncommanded acceleration hard to the left now, steering locked up, brakes locked up, tires spinning engine revving traveling 20-30 feet crashing into the electrical box coming to rest on top of it. Numerous faults showing multiple systems malfunctioning causing this incident.