general problems of the 2017 Ford Escape - part 1

The failure appears to involve the vehicle’s auto start/stop system and related electrical control systems, including the battery management system and/or body control module. The vehicle shuts off unexpectedly while driving and fails to automatically restart, displaying “auto start/stop – manual restart required” and “shift to park. ” the vehicle is available for inspection upon request. The vehicle has shut off unexpectedly in active traffic, causing a sudden loss of power. This creates a dangerous situation where I am unable to accelerate or move with traffic flow, increasing the risk of being rear-ended or involved in a collision. This has occurred on public roads with other vehicles present, putting both myself and others at risk. The issue is intermittent and has not consistently been reproduced on demand. However, it has occurred multiple times during normal driving conditions. I am in the process of having the vehicle inspected and documented by a dealership. The issue has been reported to the manufacturer, and a case has been opened with Ford motor company. At this time, the vehicle has not yet been inspected by police or insurance representatives. There were no consistent warning lamps prior to the failure. At the time of the incident, the vehicle displayed messages including “auto start/stop – manual restart required” and “shift to park. ” these messages appeared simultaneously with the loss of power. The issue has occurred intermittently without advance warning.

My vehicle was inspected by a mechanic after experiencing sudden loss of power and stalling while merging onto the expressway in active traffic. At the time of the incident, the vehicle became unable to accelerate properly, creating a serious safety hazard due to surrounding vehicles traveling at highway speeds. The mechanic determined that the fuel pump had failed. During inspection prior to replacement, the mechanic identified metal shavings present in the fuel system, which appear to have originated from the fuel pump. These metal fragments contaminated the system and pose a risk of further engine damage. This failure appears to be related to a known issue involving fuel pump defects in Ford vehicles. The design and/or function of the fuel pump may allow internal deterioration that leads to system-wide contamination and potential engine failure. This issue presents a serious safety concern due to the risk of sudden stalling and loss of power while driving, particularly during high-speed merging conditions.

Engines has a severe issue with coolant leaking into the engine cylinders due to a design defect in the engine block. This "coolant intrusion" lead to misfires, engine overheating, and complete engine failure, and is requiring a full engine replacement.

While driving at a constant speed on the highway, the transmission shifted down a gear and revved into very high rpms. I was dramatically slowing down despite pressing on the gas pedal. The car didn't provide any power and just revved while I had cars next to me going at highway speeds. Managed to get off the highway, a transmission fault indicator popped up on the dash. The car no longer was able to move. I had the car towed to the Ford dealership. This car has a bad transmission at ~97,000 miles. Prior to this, I felt like the car's transmission maybe wasn't shifting on time but didn't make much of it. This could have easily resulted in a crash. Turns out this is a very well known problem with the Ford Escape. My friend has a 2016 Ford Escape who recently paid 8000$ for a new transmission. This is clearly unsafe and the failure is definitely premature.

2017 Ford Escape 65,000 miles,1. 5l coolant intrusion. #2 cylinder misfire code. First thing upon raising the hood noticed and acknowledged there was no coolant in resevoir. Attempting to replace spark plugs. Removed/replaced #4 plug. Attempting to replace #3 spark plug, plug broke off. Researching and collaborating with reputable mechanic concluded that short block coolant intrusion has occurred. Upon disassembly have encountered turbo boost and catalytic converter full of oil, also needing replaced. Head has been sent to machine shop for inspection and repair. Presently awaiting for repairs to be completed and costs established. Present estimate over $5000. I paid cash for this vehicle in 2019. Vehicle had been leased for 2 years previous. Vehicle had 20,000 miles on it. Ford was well aware of the coolant intrusion (bad engineering) is before they sold me the vehicle in November 2019. They never mentioned or offered any warranty specific to this issue. They sold me a a vehicle knowing that if enough things went wrong while driving this vehicle, catastrophic situation was possible. They should have corrected this issue before they sold it to the next customer.

Coolant intrusion into cylinders at 81,000 miles has damaged engine and transmission pump, requiring replacement of both. Appears this is a known issue with both 2. 0l and 1. 5l engines.

Code for camshaft timing and cylinder 2 misfire. Scoped coils and performed relative compression test. Dead cylinder on number 2. Recommend manual compression test and cylinder leak down test to identify cause of low compression performed manual compression test and confirmed cylinder has 0 compression. Performed cylinder leak down test. Air coming from crankcase. This indicates an issue with rings, cylinder wall, or piston. Engine will need to be replaced. The coolant leaked into the cylinders, which lead to engine failure.

My Ford Escape 2017 at 77,000 was diagnosed with coolant intrusion, causing catastrophic damage to the engine & requiring a total engine rebuild. This is a known issue identified by Ford in csp 21n12 by Ford and tb 22-2134, but Ford has refused to subsidize any repairs because the car warranty is over 7 years old (it is currently an 8. 5 year-old car). This issue can cause overheating, engine failure, and fires & has been known by Ford since at least June 2022, but they failed to notify me via mail or otherwise & have refused all requests to grant an extension or partial coverage for the necessary engine repairs.

While driving the car- the front end started to shake and the check engine light came on. Took it to our local Ford dealership and the advised that it was a cylinder 2 misfire when they diagnosed. They advised that the engine block is porous and the coolant slowly leaks into the engine which is causing the misfire. Called Ford's customer assistance line and since the car is out of warranty- and there are no open recalls, that they will not cover the $9100. 00 new engine repair. Our car is a 2017 Ford Escape titanium- with approx 82k miles. We purchased the car as a certified pre-owned in 2021- and have had no prior issues. We did not purchase any extended warranty. We were advised that the car isn't safe to drive due to the engine misfire.

I have a coolant leaking issue, that has harmed my engine and quicklane at bill brown Ford in livonia, recommended an engine change. There is a class action lawsuit about this, so it is a known defect.

Engine light came on and then 3 days later, the car would not drive. Got the car inspected and found out the coolant is leaking into the engine.

We are having a problem with the fuel injector system and maybe the fuel pump. It seems that there is not enough fuel getting the the engine and while on the road it seems like it wants to stall or something. I have had 2 different mechanics do a obd and nothing shows up. There is no engine light that comes so they say they can't get a good read. I saw the article of Ford recalls about low pressure fuel pump may fail. I called Ford to explain what is happening and they said there is no recall. I said maybe this is the start of something and they said to contact (NHTSA). I have tried fuel injector cleaners twice with 2 full tanks of 93 grade fuel and no change at all. The Ford Escape might have the same problem with the other Fords that are being recalled. I hope someone can help me with this problem before something happens on the highway! thankyou!.

I own a 2017 Ford Escape with the 1. 5l ecoboost engine. The engine began exhibiting symptoms of coolant intrusion into the combustion chamber. A certified Ford dealership confirmed the diagnosis after inspection and advised that the engine needs to be replaced or rebuilt due to this issue. This defect is known and widespread in this engine type and can lead to engine failure while driving, posing a serious safety risk. Although Ford issued a customer satisfaction program (csp 21n12) for this exact problem, my vehicle was just outside the expiration period, and Ford has denied financial assistance, despite this being a documented and recurring defect. There were no warning lights before the engine began running rough and misfiring. The coolant loss was gradual and internal. This issue has been confirmed and documented by a Ford dealership, and I have a case open with Ford corporate. I am filing this complaint because of the safety risks involved with coolant intrusion, the costly repair burden passed to consumers, and Ford’s refusal to support a known defect that could lead to sudden engine failure while driving.

Issues described in Ford technical service bulletin 22-2229. 2. 0l ecoboost - coolant in cylinders, white exhaust smoke and/or illuminated malfunction indicator light.

The engine failed while I was driving through mountains. The car shut off and would not shut back on. The check engine light had been on for about 2 weeks.

Need a new motor at 60,000 miles. Iv never missed an oil change.

My Ford Escape was diagnosed 12/31/2024 with a slight coolant intrusion. The dealership said my Escape would require a new short block engine at the tune of $7555. 28. I still owe $5800. I bought my car 12/2020 from a Ford dealership with 3rd party extended warranty with 45k and now vehicle has 72k. Ive been having vehicle serviced at different Ford dealership located closer to my house.

Coolant intrusion into combustion chamber requires new engine. Verified by Ford dealer. Not covered by warranty. Ford technician states engine block manufacturer issue.

Our car started slipping gears, jerking, take forever to accelerate, and would lose power. We took to dealership thinking it was a transmission. They told us no it wasn’t the transmission and we needed the replace the fuel pump injector we did that. A week later same issues happened again they replaced the pump again. A month later same symptoms again this time they told us we needed our engine replaced. So we got a brand new engine in. A month later I lost power while turning onto to a highway and the dealership told me that it was the new engine breaking in. Not even 3 months later after the new engine being put in our car starts to act up with the same symptoms. We took it back since the engine was under warranty. They tell us we need a new transmission. We told them we knew it was the issue the first time around. We can’t afford a new transmission after just putting a new engine in 3 months ago! stay away from this year Ford Escape. Our car only had 116,000 miles and it’s our family car so we can’t drive it anymore cause we can’t afford another big issue to be fixed. Mainly because we think the dealership doesn’t want to admit their mistakes and won’t resolve the issue for us. Can’t believe the car has these two huge issues in one year let alone less than 6 months apart!.

Cylinder (2) misfire causing coolant intrusion in engine block . Tested and failed damaged cylinder plug causing misfire. Engine ruined!.

Coolant leaking into cylinders, smell coolant through vents, smoke from exhaust, film of exhaust coming into front windshield, turbo charger 1, under boost, car just stopped accelerating.

My son was driving this car home from school and while going through a busy street, the car suddenly buckled and stalled and he was almost t-boned. Thankfully he was not hit. We later found out that this vehicle was assembled in a plant that has a known line issue with their engine blocks. This issue caused one of the cylinders to crack and fluid to leak in causing the issue that almost caused the accident. We were made aware that this is a known issue by our service person. Ford is aware of it as they have issued csps and tsps regarding the issue but have yet to issue a recall and will not cover repair costs or offer to fix vehicles before they have the issue. Ford should have a safety recall to prevent possible accidents as these vehicles age and the problem occurs more regularly.

I was driving down the road and my vehicle stalled out and had little to no acceleration was stuck in the middle of an intersection until I could move it to a parking lot putting my safety at risk. Dealer (brondes Ford toledo) ran codes, yet would not tell me the codes after they tried to charge $11,000. No warning lights yet, had engine lights on until the dealer replaced fuel vapor assembly and crankcase pressure sensor a little less than 30 days beforehand. After service Ford said it was good to go and stated this could not have been related to the bushing already recalled.

On a routine drive, my 2017 Escape se, traveling at 68 mph on cruise control made a quick thud sound and instantly became unresponsive to gas pedal depression, and immediately began to slow down from 68mph, rapidly slowing to 30-35mph with fast moving traffic behind me. My Escape and displayed an engine light that flashed continuously, and I drifted over to the shoulder and came to a stop noticing the rough and choppy engine operation. Upon the use of a general obd ii scanner, p0300, p0301, p0302, p0303 were displayed as the cause for the engine light illumination. The vehicle was towed to a repair shop (receipt attached) and the spark plugs, coils were replaced at a cost upwards of $500. Upon the Escape being returned to me and its initial 50 miles driven, once again the engine light illuminated and the code p0302, p0303 were read once again as well as “multi cylinder misfires detected” the vehicle vibrated violently, and accelerated was deeply compromised resulting in a near miss accident from the rear, and subsequently not being able to accelerate through an intersection. This was another safety issue as opposing traffic in all directions were required to go around my disabled vehicle at risk of collision with my vehicle. Vehicle was then taken to a Ford authorized dealership for inspection and possible repairs. At that time I was informed coolant had been leaking into cylinder 2 & 3 causing continued and extensive damage to the internal working components of my 1. 5l ecoboost engine. The repair required and sugggested was a long block replacement with an estimated cost of $10,000+, surpassing the value of the vehicle three times over. I took the vehicle home and parked it, and bought a 2018 Ford Escape, and was unable to use my 2017 Escape as a trade in as it was considered a worthless vehicle due to its disrepair. Ford knows about this issue and refused assistance or advice knowing this problem exists and affects most of their vehicle lineup.

For the last few months, I’ve noticed that my vehicle’s brake mechanism hasn’t been stable, also audible /noises coming from brakes at time, vehicle has an evap leak, causing vehicle not to start after refilling with gas. Yesterday, 6/11, while traveling, there was a notice that said engine was overheated and to stop vehicle safely. I was on a restricted highway on a very slim shoulder, very traumatized, but after 3 hours successfully has vehicles towed to a repair shop. No work has started.

I had my car serviced with Ford 6/2024 for the replacement of a steering rack and pinion that cost $3,000. After repair, my check engine light came on. Ford capped all my fluids, but said they didn’t diagnose the check engine light because it would cost another $200 diagnostic fee. On 7/1/2024 I took my car to a local mechanic and he discovered I had no coolant fluid and a diagnostic test showed a misfire in cylinder 1. He diagnosed this for free in a few minutes, while Ford refused and allowed me to drive back on the road in dangerous conditions. My coolant is leaking into cylinder 1. This is due to a manufacture defect in the open deck design of the engine block. My life was put at risk on the road driving with no coolant causing damage to my engine and reducing my car’s performance. Joes auto shop confirmed my issue informing that I need a new engine costing around $8,000.

My 2017 Ford Escape has a 1. 5l ecoboost engine that has been leaking fuel into my cylinders. My mechanic says I'm lucky it didn't cause a fire while I was driving it. Due to the damage, I now have to replace my long block engine, quoted at $11. 2k. A week after I bought the car in late may 2024, the car began to smell of gasoline whenever I used my a/c, which I rarely do. A constant problem I've experienced since purchasing this car is misfiring, specifically cylinder two misfires. Ford needs to recall these engines, as I believe their design is faulty and these problems could have been prevented. The longer they refuse to acknowledge the problem they've caused, the more time unsuspecting people such as myself can drive around their new Fords and potentially have their cars burst into flames.

My check engine light on causing vehicle to run rough. And delay in engine performance. (transmission shifting). Ford dealer replace several emission parts. (warranty. ) . Purge valve system. Oxygen sensors etc. Car in shop for 12days. Pick vehicle up drove 2miles check light came on again. Back to Ford, now Ford wants me to pay for needed repairs to charcoal canister, purge valve system. $400,00 to $ 800. 00. This repair is epa and federal emission policy. Which fotd and dealer states no it's not. Dealer will not help with any assistance. Tried to explained Ford and federal. Epa rules. Per Ford warranty parts statements and policy . Dealer 1st stated to me this part is under extended Ford warranty. Hours later called me back,stating it's my responsibility to repair. This part is electric vacuum operated. Prt# gv6z9d333a purge control valve (block off switching valve ) which is a hose and solenoid assy. The say it's a hose nothing else. I explained a hose is only a hose and has nothing to do with opening and closing of emission purge valve . System. That is what the solenoid is for which opens and closes purge system from fuel tank vapors system to charcoal canister. Please help me in this repair clarification.

Coolant leaked out, and ran hot. Refilled coolant and it didn't leak out but still runs hot. Mechanic said the car runs hot as soon as it’s turned on; coolant is leaking into the cylinders or warped cylinders causing engine block cracks. Another problem is when I get fuel and start the car back up “auto manual restart” comes up on the dash and car shuts off. Car also sputters then shuts off every time I turn it back on after that until I press the gas pedal a few times. Has been smoking since April of 2024 but coolant problem occurred sometime in January of 2025. Fuel issue had been happening since September of 2024.

The engine broke down and coolant was coming in somehow. It required a total engine replacement.

The oil pump failed due to the coolant intrusion into the engine, causing low pressure and sludge. My mechanical breakdown warranty inspected it and will not cover the replacement due to the sludge. The check engine light came on and off after I hit 70000 miles, and I was alerted to a recall when I got my last oil change in March of 2024, but the Ford dealership stated I had no warranty and no recall to address.

Vehicle indicated on the on board information screen that the engine has misfire and service engine soon. Inspected and noticed coolant lower than normal and engine would idle different. Took to dealer for check engine light. Inspected by certified technician and was told the coolant was "washing the cylinder walls of cylinder 2 and dripping into cylinder 3 causing misfire and coolant to enter the combustion chambers and exhaust system ". Fords only fix to this was a complete engine replace. Quoted $8500 to replace. Was told by service writer that Ford has known about this problem on numerous models and passes the repair bill to the customer with no help. This vehicle transport my 3 children and wife daily. After further review this could cause the engine to over heat cause the oil to become a the cooling solution until it the vehicle will stall and could bust in flames. One engine code indicated that the evap system has malfunction and could not release the gas vapors from fuel tank. Which will cause the tank to explode with no warning. I bought this vehicle brand new and had services done when needed. 122k miles on a 6 year old vehicle and needing to replace a engine is not suppose to happen especially with a manufacturer that claim they are the leading manufacturer for the most sold and safest vehicles in America.

The **engine system** failed due to **coolant intrusion into cylinder 2**, causing engine misfires and loss of power. This condition is consistent with known ecoboost engine defects in this model year. The vehicle is available for inspection upon request. This failure created a **safety risk** due to potential **loss of power or stalling while driving**, increasing the risk of a crash. An additional issue exists with the **electrical system**, specifically the **driver’s door control panel circuit**, which intermittently malfunctions and affects vehicle operation. The engine issue has been **confirmed by diagnostic trouble codes indicating a cylinder 2 misfire**. Dealer confirmation: **unknown**. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. Prior to failure, the vehicle displayed a **check engine light**, rough idle, and misfiring. Electrical issues occurred intermittently. Exact onset date is **unknown**.

My car suddenly stopped accelerating. No warning lights came on. If I had been on a freeway, it could have been catastrophic. I had car towed to sunrise Ford who said I needed a new turbo boost, turbo charge assembly and vct solenoids. I authorized that repair as cat only has 65,000 miles. After that repair, while the car was being test driven by the service technician from sunrise Ford, the car failed again, completely immobilized and the tech pushed the car off to the side of the road. Now they say I have complete transmission failure and have to spend 7000-9000 to replace the transmission at 65,000 miles. It seems like a defect that could put other drivers at risk! it should be looked into as I hear other Fords have had issue with the turbo boost and transmission.

The high pressure fuel pump failed causing damage to cam and shavings in motor. The mechanic said engine needs to be replaced. I could have been driving on the interstate instead of a back road when this happened and I lost power. Lucky for me I wasn't. It could have been very bad. Ford has had a service bulletin out on this issue for some time. I had to go to 3 different mechanics before one would even touch it. They all said the same thing. You will need at least a new cam probably a new engine per the service alert. Ford says those mean nothing and they can't help me. If I had been on interstate and crashed then maybe they would talk to me.