One problem related to carrier/rack has been reported for the 2006 Ford Escape Hybrid. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2006 Ford Escape Hybrid based on all problems reported for the 2006 Escape Hybrid.
Wife and I were enroute home from vero beach, FL traveling west on FL hiway 60 about 10 miles east of the FL turnpike around 8:30 am. Traveled over short stretch of repaved road. At that time heard beep, noticed red brake light and amber abs light on. Cruise control on moving 60 mph. Tried brakes, noticed excessive brake travel, but still had some brakes. Continued on until turnpike junction. Pulled off road, stopped, shut off ignition. Upon restarting (after 5 seconds), warning lights stayed off, had good brakes. Proceeded 130 miles to home w/o incident. This has occurred 3 times before and have had it to the dealer's service dept. On July 5th. I am detailing this incident because I have the most information about it. When it occurred all 4 times, it was either after crossing railroad tracks, hitting a pot hole or in this case after a change in road surface. And it doesn't happen all the time when crossing rough surfaces. The dealer (nick nicholas Ford in inverness, FL) cannot seem to find and fix this. I have to ground this vehicle because I cannot trust it with my wife driving by herself. It could cost up to 7k for Ford to swap out componets to try to fix it - my cost. This is a safety issue! not a wear and tear issue.