general problems of the 2000 Ford Expedition

The contact owns a 2000 Ford Expedition. The contact stated that while attempting to refuel, the fuel nozzle would constantly click off. After removing the fuel filler tube, the contact discovered that the fuel filler screen was clogged with plastic debris from the inner lining of the filler tube. The contact indicated that the debris had also clogged up the fuel filters and caused the engine to sputter and hesitate while driving. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 200,000.

Just stopped at stop light, pulled away and heard a small popping noise, slowed down to turn corner to try to pull over and look and vehicle started popping like a popcorn popper. Thought it was muffler(s). Got under car to look nothing wrong there, proceeded to go back home. ( less than 5 blocks away) driving on (coasting) only using gas pedal to make it into driveway. Got under hood and seen spark plug laying on engine, coil looing like it had caught fire. Replaced wire, plug and put a helix coil on it. Drove for about a month. Same thing happened again. Had mechanic "rethread" the head and use "sleeve". This lasted about another month. Had to replace it 3 more times (always the same plug that popped out) until August 2 when it didn't even make it out of my driveway before it popped again. Now it is sitting in my driveway, a 5100 pound "lawn ornament" not looking forward to replacing the head.

I was returning home from a family trip going the posted interstate speed limit of 65 mph when I heard a loud popping noise that sounded like a major leak had just occurred. When I pulled over to check out the problem I discovered the rear spark plug on the passenger side had ejected itself destroying the threads that hold it in the cylinder head and also destroying the heli coil pack that sits on top of the spark plug. I have never filed a complaint or safety report on any vehicle I have owned. This time the only reason I am filing a report is due to the frequency this problem seems to have on Ford triton motors. It seems excessive and upon very little investigating on my part I have found that every person I have talked to about it either owns a vehicle with the said motors in them and have experienced this problem on multiple occasions, or is someone who knows a person who has experienced this issue. I am a dedicated and loyal Ford owner and always will be, however I also believe that when a problem occurs with such frequency that they should be required to step up and make good on issues that clearly have been going on for well over a decade at this point in time.

2000 Ford Expedition spark plug blew out of the cylinder that it screws into causing loud tapping, banging noise.