Seven problems related to body have been reported for the 2003 Ford Expedition. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2003 Ford Expedition based on all problems reported for the 2003 Expedition.
Bought truck 3/2/22 from gold cauto in troy NY. 3/7/22 went to take kids to school 2. 5 inches of water set in my weather guard mats. Seats soaked console everything in front cab reversed to pull out spot and water starting pouring on my and my kids from sides in pass sides front and the front windshield area omgand the sun roof was worst. Kids had to go in myslef too it was snow still out. So that dayi OH sunroof needs to be blown out I said well that right frontdoor sounds open when its shut . Same night I picked it up said all was good to go and his guy didn't hear any issues with door. The next snow it was worst this was about toward end of March. I called back around 3/15 said its still leaking dude I just want my money back for real and we are good, he said no doesnt work liek that said all his winshield guy he would take a lok at it and tell hijm ihe sent me. Did that talked to the guy said he woudl call me the next day week went by so I called him back long story short he said he wasnt fixing it josh the dealer never pays him , I understood. Called talked joshgoldstien told him he said well u just have to bring it in and let me have it for a few days he knows I could not not do that . Leave because by now im having to leave apt and in hotel w/2 kids and im not even from here I know nobody. Kids have to bev icked up ad dropped off no buses. I didnt and dont trust his people by this time so I didnt it comes out now the truck is dangerous the airbag on right side light has been von since I bought he said it was old truck it was fine no its busted the air bag. The right front seatbelt now is broke it would have to be completely replaced this in 2. 5 months. Then find truck is like flintstones the front cab from yrs I guess leaking is gone literally my 5 yr old fits the cab from underneath its should have never been inspec. The day I bought vthe refused to trade or give refund cussed and screamed at me whenever I came lights turnoff at night form damage nooil.
Frame rot in multiple locations, front and rear.
The contact owns a 2003 Ford Expedition. While driving 50 mph, the vehicle began to vibrate. The failure recurred on numerous occasions. The vehicle was taken to an independent mechanic who diagnosed that the front passenger side subframe corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 186,000.
My passenger window and both back windows have dropped several times. I have had to have this fixed more than once on the back passenger side window, what happens is ill try to put the window up and the window motor makes a struggling noise and I am unable to roll up the window. At this point I'm sure it must be a defect because of how it has happened to each window more than once. Also the bumper that goes around the entire car is extremely faded and I am unable to get fixed I have gone to get estimates for a pain job but have been told due to the material it is just going to fade I would need to get it sanded and have them do some special treatment I cant afford and they will not just paint over it for me because they guarantee there work and would have to redo it too often. All the Expeditions I see have the exact same issue.
I owned this vehicle since 2003. A couple of years ago I noticed small perforation/rusting on the top of the vehicle and over time it became worst. Now there are numerous badly corroded areas . It appears that due to the design and the materials used water remains trapped especially when the vehicle is parked. Also poor workmanship or poor materials are contributing factors. This may have caused this unforeseen issues. There is a possibility that the hood can become weak in the areas affected by the corrosion, therefore I am seeking guidance. I did reach of to the Ford company with negative results, they only advise that this was not a warranty issue. On another note I am the only owner and I have not lived close to the beaches or even where you would expect corrosion of this magnitude.
The contact owns a 2003 Ford Expedition. The contact stated that while driving 25 mph, the driver's door opened without warning and would not remain latched or closed. The dealer had not been notified of the failure. The manufacturer was made aware of the failure but did not offer any assistance. The current and the failure mileages were 108,000. The VIN was unavailable.
When it rains the rear doors of the vehicle fill with water. I have done everything I can to make sure the door is sealed but it still fills up with water. It has rained a lot this week and the doors are full again.