Six problems related to fuel pump have been reported for the 2005 Ford Expedition. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Ford Expedition based on all problems reported for the 2005 Expedition.
Vehicle stoped running on flat level read at 65 miles per hour. Vehicle would not restart. Vehicle had been stalling prior. Mechanic cant pinpoint problem but feels fuel pump, fuel pump module, fues box malfunction are the cause. To many stories of this problem surfacing. My family in danger with vehicle stopped on major highway, caused by a well known problem Ford is aware of.
Vehicle has been stalling for almost a year. Vehicle shut off on busy highway and towed to nearby repair shop. Mechanic found fuel pump control module completely corroded from behind and circuit board exposed to moisture. The fpcm fried and shorted out one leg of the fuel pump. Both pieces had to be replaced. New fpcm installed was obviously redesigned so module would not suffer this flaw again. I am finding an alarming amount of complaints on the internet of Ford Expedition owner experiencing the exact same problems under more dangerous conditions.
The contact owns a 2005 Ford Expedition. The contact stated the fuel pump driver module failed. The contact stated while driving 65 mph the vehicle stalled without warning. The fuel pump driver module was located in the rear of the vehicle near the fuel tank. The failure destroyed the fuel pump and blew the 15 amp fuse that allows the fuel pump to function. The dealer informed the contact that the part was currently on back order. The failure and current mileages were 103,000.
The contact owns a 2005 Ford Expedition. The contact was driving approximately 10 mph when the engine stalled without prior warning. The engine failed to restart and the vehicle was towed an authorized dealer where the fuel pump driver module was replaced. The failure mileage was 66,859. Updated 05/05/lj.
2005 Ford Expedition eb fuel pump broke at 65000 miles. Auto bought brand new and in excellent condition. Ford dealer and Ford rep cannot locate the replacement pump. . Said it will be late February if I am lucky. This is my main mode of transportation!!.
I own a 2005 Ford Expedition (limited) on a number of occasions my vehicles motor has revived up and I had to put my foot on the brake very hard to prevent crashing into vehicles in front of me. . . It also happened one time when I was going about 50 mph and the car for now apparent reason accelerated to 60 very quickly. I have reported this to the dealer on three separate occasions and they advise that there is nothing wrong with the vehicle. (maroney Ford, delray beach, FL).