general problems of the 2012 Ford Expedition

I was driving my 2012 Expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My VIN number does not fit the recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had I not known how to drive I and my daughter would be in the hospital due to the faulty transmission lead frame and power train . I contacted Ford head quarters they were no help even though there is clearly a recall . I also took the truck to Ford of valparaiso and had to pay the 1,000 dollars for the lead frame to be replaced which was in the recall and I shouldn't have had to pay anything . . Them replacing the lead frame did nothing the car is still not drive able and is extremely unsafe its my only vehicle and I am a single mother of 2 kids .

I just purchased (2 months ago) a 2012 Ford Expedition el 5. 4l v8 from a private party. I wish I would have done more research as I am already experiencing transmission issues that I believe are directly related to the vehicles lead frame recall. It threw a p0742 code on me torque converter clutch circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this unexpected shifting into 1st gear at highway speeds is, it is equally as dangerous to be getting out of your vehicle in moving traffic due to Ford's terrible design on this vehicles power train/transmission system. I have scheduled an appointment with the local Ford dealer and al certain I'll get the runaround/blame game for this one. 150k miles and as I said, I have owned it for 2 months and have already had transmission issues, brake issues, belt tensioner pulley literally fell off. . And from what I read, what's next??? the cam phasers?? that's if the transmission issue is even fixed and it becomes safely drive able again. Come on Ford, get your act together, you're better than this!.

July 2025 my 2012 Ford Expedition threw a p0742 code for a stuck torque converter clutch. The vehicle had just under 150k miles and started to jerk in and out of gear and the wrench light illuminated so I, thankfully was going approximately 45 mph when it happened and was able to pull the vehicle over as it was in limp mode. When I cleared the dtc code the problem went away temporarily but eventually locked back up again within a mile from my home. Unfortunately, Ford dealerships will not stand behind the customer service number that they have listed for a replacement of the transmission lead frame. I provided the local dealership with all of the necessary information as well as an independent diagnosis by a transmission specialist. Looks like I'll just have to wait for the day that it causes a massive accident by downshifting into 1st gear at 65mph. Terrible customer service and I can only hope this doesn't cost someone their life.

The transmission jumps in and out of gear, the engine revs on its on. I was on the highway the first time and I going between 60 and 65 mph and it sounded like the whole bottom of the truck was just ripped out, the truck went from drive to either park or first gear it locked up the back tires and there was a truck behind me he tried to miss me but he hit the back passenger side of the truck. He was very very upset he threatening and cussing me because he thought I just slammed on my brakes for no reason. I explained to him what was happening and calmed down think god. It could have killed him or me or even several other people. When it locked up the tires then it jumped back in drive and tried tot take off, I threw it in neutral and cut the key off. That scared the sh. . Out of me!! I have talked to other people that have around the same year model truck as mine and some of them are having the same issues with it jumping in and out of gear not wanting to shift gears revving up on its own and no engine light comes on I've tried to get a code scanner scan it no codes come up on the truck Ford needs to fix this truck they had a recall on certain models that were manufactured at different plants or something like that I heard but they won't fix my truck they said it's not under recall this truck is going to kill somebody it's the only truck I have and I have to go to work I'm just asking if you can please do something about this before people get killed in or I get killed I'm going to try to get a video of what it does I'm just asking if you can please do something about this Ford knows what the problem is I read stuff on it and they need to fix these trucks before it kills people they know what the problem is if I have a bad wreck and I live to it or this truck causing somebody to lose their life it's going to be a multi multi multi million dollar lawsuit because they refuse to fix the truck I'm just asking you if you can please do something about this thank you.

My vehicle suddenly shifted downward, my gas pedal had no effect, my speedometer stopped working and my fuel and tire sensor lights came on. This happened multiple times on my drive this morning and would have caused an accident if I was being tailgated.

Driving on a highway at approx 50 mph, vehicle speedometer goes to 0, mileage goes out, dash lights flash, wrench light comes on, vehicle downshifts (has done this several times (sometimes accelerated from 1st gear)) to 1st gear and goes into a limp mode. Had to pull over and shut off the truck- all fine when restarted. Could have caused a major accident. Very scary. This truck has had a recall repair fixed for what was described as exactly this problem. Has happened numerous times now.

Recall TSB 13-6-8 vehicle built in kentucky truck plant July 2012 equipped with 6r80 transmission exhibits engagement in 5th gear. Wrench light comes on, speedometer reads zero and odometer displays dashes while driving. Ford states it is not part of recall. Ford diagnosed problem with solution of replacing molded leadframe.

Vehicle downshifts abruptly while being driven at approximately 55 to 60 miles per hour. Very dangerous, it can cause an accident. Some vehicles were recalled but Ford says my VIN number was not in the vehicles that were recalled. The description of the problem is exactly as the one described to the recalls in 184,000 Ford vehicles from 2011-2012. A wrench shows up in the dash board and a sign that shows low gasoline levels. When this problem occurs the only option is to pullover as fast as possible. I stopped turned of the car and turned it back on. After the car would drive normally without showing anything on the dashboard and without any problems. I have experienced this in the last 3 weeks at least 7 times. When a scanner is connected it does not show any signs or problems. Very dangerous experience every time it happened. It usually happened at a high speed in the highway which makes it even a more dangerous situation. It happened while the vehicle was in motion and being driven over 55 miles per hour. It feels like it downshifts from 5th to 1st gear without any reason. Only while driving 55 miles per hour or more. It relates to recall 12v190000 and it seems like Ford promised to replace the "lead frame" which causes this defect at no charge under 10 years or 150,000 miles. They say my VIN number does not have recalls. I firmly believe that the symptoms of the problem are exactly the same as what all the 184,000 cars between 2011-2012 had experienced. It is an extremely dangerous situation to be in. I also found that in the past 3 cars were involved in accidents due to this issue and thankfully no fatalities. I do not want to be involved in an accident due to this negligence from Ford. Please hold them responsible and acountable for their poor accountability.

When driving the car in motion at speeds over 40 mph the breaks would lock up and the car would come to a complete stop.

Stopped at 0mph. Witness in car behind. Foot on brake. Touched accelerator normally. Heard noise. Car took off at high speed. Hit wall approx twenty feet away. Both front airbags deployed. No one in passenger seat. Seat belt on, per driver, witness who helped driver thru window, and examination of seat belt by inspector. However edr read seat belt as not engaged. Brake read as not engaged, however edr also read vehicle at 0mph. Accelerator 0% at 3. 5 seconds prior to impact, initial acceleration 23% three seconds prior to impact, 99% 1. 5 seconds prior to impact. Engine rpms data may not be appropriate. Multiple vehicles using remote controls at nearby gate.