Other Fuel System Related Problems of the 2021 Ford Expedition

Table 1 shows one common other fuel system related problems of the 2021 Ford Expedition.

Table 1. Other Fuel System related problems of Ford Expedition

Problem Category Number of Problems
Other Fuel System problems
6

Other Fuel System problem #1

Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no reports of bad gas. Towed to repair facility where dead fuel pump was diagnosed and replaced. Ford recall 25s75 includes some 2022 Expeditions but not this 2021 with only 43,000 miles and no previous issues.

Other Fuel System problem #2

Fuel pump failed in express lane, unable to move the vehicle from travel lane under its own power.

Other Fuel System problem #3

The fuel pump failed without warning leaving the vehicle stranded in the express lane of a highway. This exposed the vehicle and occupants to serious risk of collision. The vehicle does not allow the transmission to shift to neutral to move the vehicle from live traffic lane when the engine is not running. This is the same fuel pump model at the heart of the ongoing recall on other Ford vehicles.

Other Fuel System problem #4

Fuel pump part number jl1z*9h307*g failed at highway speed leaving vehicle stranded in express traffic lanes. But for the prompt response from fhp this would have resulted in a serious crash. The vehicle has almost never been operated below 30% of fuel capacity and has never been operated to near empty fuel. There are no known wear or accidents that impact the fuel system. There were no warnings or other symptoms prior to the complete pump failure.

Other Fuel System problem #5

Vehicle stalls out upon driving when trying to accelerate. Has popped up error which states to check fuel pump.

Other Fuel System problem #6

My catalytic converter of my 2021 Expedition is going out. We had a 2019 Ford Expedition texas edition and I had the same issue. We purchased our current Expedition in April of 2023. This spring the converter was signaled with the check engine light and since then my vehicle has had issues with acceleration, it consumes gas at an extremely high rate and my engine works harder over time. My concern is that my vehicle will have an engine malfunction or put me into bankruptcy by the amount of gas it consumes per trip. I found that many other Expeditions from the years 2018-2022 have similar issues to mine, in fact one of my friends in town had the same issue. I reported my issue to Ford and they said they would not repair. My vehicle has less than 80k miles on it.


Other Fuel System related problems in other Ford Expedition model year vehicles:



Expedition Service Bulletins
Expedition Safety Recalls
Expedition Defect Investigations