Two problems related to warnings have been reported for the 2025 Ford Expedition. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2025 Ford Expedition based on all problems reported for the 2025 Expedition.
On August 11, 2026 at approximately 5:17 pm, the vehicle was traveling about 25–30 mph and approaching a stop sign. The driver began braking normally, but the vehicle did not adequately slow despite repeatedly pressing the brake pedal. The vehicle continued completely through the stop sign and intersection. Fortunately, no cross traffic was present and no collision occurred. After passing through the intersection, the vehicle slowed while traveling uphill. At approximately 5 mph, the electronic parking brake automatically applied by the vehicle and brought the vehicle to a stop. After being placed in park, the vehicle would not shift out of park and displayed multiple fault messages. Fordpass recorded simultaneous faults for antilock brakes, electronic parking brake, powertrain malfunction/reduced power, pre-collision assist, and blind spot/cross traffic systems. One message specifically stated that the anti-lock brake system had detected a fault and was disabled. After several power cycles, the vehicle could be moved, but an orange wrench remained illuminated and cruise control was unavailable. After being shut down for approximately one hour, the warnings cleared and the vehicle appeared to operate normally. There were no warning lamps, messages, or braking symptoms before the failure occurred. Because the vehicle failed to respond normally to braking and traveled through an intersection, the incident created a serious risk of collision, injury, or death. The vehicle was subsequently towed to an authorized Ford dealership and is currently available for inspection. Dealer diagnosis is pending. The dealer has been asked to preserve the diagnostic trouble code/fault history and investigate the brake, electronic brake booster/abs, electrical, and related control systems.
The pre collision avoidance system doesn’t activate at all even though the adaptive cruise control works properly. Has been seen and evaluated by dealership technician as well as having a Ford engineer remotely logged into the vehicle. All modules have been updated and the issue still isn’t resolved. I was told by the dealership to take it to a different dealer or figure it out on my own.