Two problems related to starter have been reported for the 2002 Ford Explorer. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2002 Ford Explorer based on all problems reported for the 2002 Explorer.
This 2002 Ford Explorer eddie bauer abruptly stops while driving at any speed without any notice or indication that the ignition will fail to keep the car running. This car has been to two Ford dealerships and one reputable and established independent automotive repair shop. This car was at a Toyota dealership for almost 30 days and this car was returned to me with this potentially fatal defect still undiagnosed. None of the aforementioned dealerships could determine the true underlying problem. At the Toyota dealership a brand new starter was installed because of a no start condition showing no power to the starter and blown fuses for the injectors, fuel pump, and the computer. The same defect showed itself one day later after traveling over 70 miles with no sign of failure.
Ongoing shifting and slipping within the transmission. Also a loud shrill at the end of the acceleration. The transmission converter has been replaced multiple times and the transmission leaked out fluid at highway speed. After the repair of a stripped transmission line connector and a pile of glue to fix a broken electrical connector the vehicle was returned to service by the dealership and the warranty company. The converters are "remanufactured" which have been known to fail. The glob of glue on the electrical connector will be reviewed by the state as to the proper repair procedure. A law suit may follow due to separate repairs including a tire with a nail, where a new tire was purchased and a used on was installed (bf goodrich). The tire was also not balanced and was off by 1. 5 oz. There was also a gasket removed from the cooling system that caused antifreeze to spill out onto the engine. The cooling system had been serviced two months prior and was never leaking until the day the vehicle was returned. There was also the discovery of the positive electrical harness to the starter having exposed wires due to the oil filter drain housing made of plastic rubbing against the wires. There are three wires exposed and there may be the potential for fire.