Wheel Bolts problems of the 2002 Ford Explorer

The contact owns a 2002 Ford Explorer. While driving approximately 10 mph, the contact noticed that the rear passenger side tire rode roughly. The contact noticed that three of the wheel studs were sheared off. The failure occurred four times with the remaining wheel studs. The vehicle was not diagnosed or repaired. The manufacturer was notified. The approximate failure mileage was 140,000.

- the contact owns a 2002 Ford Explorer. While driving 65 mph, the vehicle started vibrating and pulling to the right. A lug nut hit the windshield and the vehicle came to a sudden stop because the front passenger side tire was lodged underneath the vehicle. The vehicle was towed to the dealer to replace the new lug nut and stems and repair the damage to the vehicle. The failure mileage was 71,000. The current mileage was 81,000. This failure has occurred on tow occasions.

: the contact stated while driving 15mph the right rear wheel wobbled. The vehicle was taken to an independent repair shop for inspection. The mechanic determined that the lug nuts were broken which resulted in the loose rear wheel. The mechanic replaced the broken lug nuts.

I was driving down county road branch, it felt like I was driving on a bumpy road (what it feels like when your tire goes flat) I turned on lateral b south, then it got worse, so I stopped and checked all tires, they were all okay, then I start driving 20 feet further then I stopped again, my oldest son took of the hub and discovered 3 out of 5 bolts with lug nuts were broke off in the right rear passenger hub.

I had 1 wheel stud break and ordered a replacement from dealer. Wheel studs only come in packs of 5. Wheel stud replaced and about 4 months later 2 more broke simultaneously.

Driver rear tire separated from vehicle. The failure was the result of the lug nut breaking. The vehicle sustained a dent hub cap, and light damage to the left rear bumper and panel.

On 8-10-01 I was driving a hertz car rental 2001 0r 2002 Ford Explorer on I-75 to the atlanta airport. I began noticing "shimming" in the steering wheel. Soon after the "shimmying " became worse and I experienced excessive "play" in the steering wheel. I pulled onto the shoulder without incident. Later, a tow truck driver discovered that 3 out of 5 lug nuts had been sheared off completely - - causing the right front wheel to "wobble" significantly when rotating. If the wheel had come off the vehicle, it could have resulted in very serious injury/dealth - - especially on busy truck lader I-75 just north of atlanta. Just want you to be aware of this serious matter.

On 8-10-01 I was driving a hertz car rental 2001 0r 2002 Ford Explorer on I-75 to the atlanta airport. I began noticing "shimming" in the steering wheel. Soon after the "shimmying " became worse and I experienced excessive "play" in the steering wheel. I pulled onto the shoulder without incident. Later, a tow truck driver discovered that 3 out of 5 lug nuts had been sheared off completely - - causing the right front wheel to "wobble" significantly when rotating. If the wheel had come off the vehicle, it could have resulted in very serious injury/dealth - - especially on busy truck lader I-75 just north of atlanta. Just want you to be aware of this serious matter.