Three problems related to engine clicking and tapping noises have been reported for the 2003 Ford Explorer. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2003 Ford Explorer based on all problems reported for the 2003 Explorer.
Tl - the contact owns a 2003 Ford Explorer. The contact stated that while driving approximately 40 mph, the contact heard a clicking noise coming from the a/c heater blend door actuator. In addition, the a/c failed to operate. The vehicle was taken to the dealer for diagnostic testing. The technician advised that the blend door actuator needed to be replaced. The manufacturer was made aware of the failure and advised the contact that the vehicle was not included in any recalls. The vehicle was not repaired. The approximate failure and the current mileage was 110,000. The VIN was not available. Kmj.
There was a clicking noise in the dash when I turned the heat on. One day there was one more hard click and after that no more heat. So now when I turn the heat on there's a clicking noise and no heat, when I turn it on cool the clicking noise stops.
When we starte d our car for the first time after it had sat at an airport parking lot for a week, we heard a ticking noise upon start up ouf our vehicle (2003 Ford Explorer eddie bauer with v8 engine). Upon taking it to a repair shop they stated the noise is coming from the value guard area in the would need to replace both cylinder heads (per Ford need to replace both & cannot replace just one). The cost of this repair would be $4,000. 00. Upon further research, it appears that this is a common problem for our model & year. With all the other problems we have had to pay out of pocket for, it would be nice to have Ford look into this issue and possible have a recall. Thank you.