general problems of the 2019 Ford Explorer

My Ford dealer will not check 4 wheel alignment at no charge to me. I have two articles that it is mandatory to do a 4 wheel alignment after replacing the rear toe arms on my 2019 Ford Explorer.

The contact called on behalf of the owner of a 2019 Ford Explorer. The contact received notifications of NHTSA campaign numbers: 24v031000 (structure) and 26v101000 (suspension). The contact stated that after the vehicle was stopped at a traffic light, the vehicle stalled. The battery warning light was illuminated. The contact was able to restart the vehicle. The contact stated that the failure was occurring every other day. The vehicle was taken to an independent mechanic. The independent mechanic replaced the manifold absolute pressure (map) sensor and an unknown sensor; however, the failure persisted. The contact stated that on a separate occasion, while the vehicle was idling, the vehicle stalled. The vehicle was restarted. The contact stated that while the temperature gauge was midway, the vehicle stalled. The battery warning light was illuminated. The contact stated that whenever the temperature gauge was midway, the vehicle would stall. The vehicle was taken to another independent mechanic who replaced a fractured spark plug and the timing chain. The vehicle was repaired; however, two months after the last repair, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

Suspension issue causing premature inside tire wear which can be fatal, if not deadly. Multiple cases have been recorded and found among other owners for this same make and model yr. Even after parts replacement and 4 wheel alignment was completed.

Rear left toe link failed while entering a curved freeway on ramp. Failure caused the vehicle to lose traction in the rear causing the vehicle to fish tail. Advanced drivers training prevented a collision but the vehicle swayed back forth due to the forward momentum. By a miracle there was no collision because it was a narrow two lane road, with no shoulder and was between concrete wall and guardrail.

I was traveling on the interstate (~75 mph) when the rear of my vehicle suddenly jerked to one side with enough force to cause a loss of control. There were no lights or warning sounds to indicate that there was anything wrong with the vehicle in that moment or leading up to it. I was fortunate enough that no contact was made with any other vehicles as my car crossed all three lanes; from the center lane to the far right and then back across all three lanes to the far left. The car skidded off the highway and slid onto a sloped embankment before it stopped. Obviously, I or someone else could have been seriously injured or even killed. I was able to drive the car back up on the shoulder of the highway. Everything was functioning properly except the steering. I was able to drive at ~15 mph to the nearest exit. I was then towed to my mechanic's shop. The tow truck driver said it looked like my right rear tire was about to "fall off" and that I was very lucky. My mechanic took pictures of the damaged part (right rear toe arm) both on the vehicle and again once removed. He checked with Ford for a recall and found out that this part had been part of a recall on Explorers from 2012-2017, but not on the 2019. Assuming the part had been redesigned after 2017, he ordered a replacement for the right. (the left toe arm was not damaged. ) however, once the replacement part arrived, it was a completely new design from the 2019 toe arm. He recommended I replace the left toe arm as well since the parts were so different. My right shock absorber was also damaged in the accident and had to be replaced.

Rear toe link and bushing issues. I have the same car as my sister. She has a 2016 with the same rear toe link as my 2019 and her car is covered under the recall and mine isn't.

The contact owns a 2019 Ford Explorer. The contact stated they were hearing a clinking and bad rattle on the right rear wheel of the vehicle. The noise comes most when on rough roads. The contact inspected the rear right toe link seemed as though it was loose and was malfunctioning. The contact did not take the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage 46,172.